Sabre 30 - Page 15

3/21/2017 Sabre30OwnersManual
15/81
EngineModel_________________________EngineSerialNo._______________
DateofCommissioning________________DateofDelivery________________
Thefollowingchecklistshouldbefollowedasapartoftheminimumdealercommissioning
procedureforaSabreyacht.AllworkshouldbecarriedoutinaccordancewithAmerican
BoatandYachtCouncilStandards,U.S.CoastGuard,theSabreOwner'sManual,and
additionalmanualsprovidedforengineandotherequipment.Failuretocarryoutthis
proceduremayinvalidatemanufacturer'swarranty.
1:00BEFORELAUNCHING
1:01___Repaintbottomatcradlepadsandatbottomofkeelwhileboatissuspendedin
slings.
1:02___Installknotmetersenderunit(option).
1:03___Checkpropeller,propellershaftnuts,cotterpin,strutandcutlassbearing.
1:04___Checkactionofrudder.
1:05___Inventoryalllooseequipmentandreportallshortagesand/ordamages.
1:06___Installzinconpropellershaft(Dealersupplied).
2:00LAUNCHING
2:01___Checkactionofallthruhullseacocks.
2:02___Checkallhoseclampsonengineandenginefittings,exhaustlinesandcockpit
drains,headsandallthruhullfittings.
2:03___Checkshaftlogandstuffingboxpackingnut.
2:04___Watertestwindows,hatchesanddeckfittingsforleaks.
2:05___Checklifelinestanchionandrailsetscrews.
2:06___Checklifelineturnbucklesandendfittingsandtensionaccordingly;secureand
tapecotterpinsand/orrings.
3:00RIGGINGANDTUNINGOFSPARS
3:01___Inspectwireriggingforkinksordefects.
3:02___Installstandingriggingonmast.Openallcotterpinsfully.
3:03___Installspreadersonmast,securelyfasteninguppershroudstospreadertips
withstainlesssteelwireorendcaps.Spreadertipbootsshouldbeinstalledtoreduce
sailwear.
3:04___Checkoperationofallmastlights,antennawires,andaccessoriesbefore
steppingmast.
3:05___Checkoperationofallhalyardsandlifts.Lubricatesheavesifnecessary.
3:06___Installmastheadinstruments(option).
3:07___Stepmastandinstallboom.
3:08___Adjustriggingtensiontoassureastraightmastwhenboatisheeledat25
degrees.Seestandingriggingadjustmentinowner'smanual.
3:09___Secureturnbuckles,clevispinsandcotterpinsandprotectwithtape.
Turnbucklebootsarealsodesirable.