Sabre 30 - 15:00 STEERING SYSTEM

3/21/2017 Sabre30OwnersManual
32/81
1.Mainmasttrack  #6metalmastflatinternalslides
2.Mainboomtrack  Slottedinternaltrack,7/16"slugs
3.Headboardshackle  Schaeffer9380
4.Maintackshackle  Jawopening3/4",jawlength1"
5.Setbackoftack  1/4"fromaftfaceofmast
6.Setupoftack  11/2"abovetopofboomtrack
7.Clewouthaul 
Shackleonslide:jawopening1/2",jawlength1",pin
diameter1/4",setup11/2aboveboomtrack
8.Luffslidestop  Fitted5"aboveblackband
9.Gooseneck  Fixed
10.Mastcircumference  1'7"
11.Boomcircumference  1'0"
12.Jiffyreefing 
2setsofjiffyreefinghardwareareprovidedstandard
witheachboat

HeadsailData:
1.Headstaydiameter  1/4"
2.Headstaylength  a.SeriesI:41'10"
(pintopinincluding
turnbuckle2/3open)
b.SeriesII:43'51/4"
3.Turnbucklelength  1'3"extended
4.Halyardshackle  NicroFicoNF11000S
5.Tackshackle  NicroFicoNF11000P
6.Setbackoftack  11/2"aftofheadstay
7.Genoatracks 
SeriesI:10'outboardtrackontoerailwithafterend
5'5"fromtransomcorner.10'inboardtrackwith
afterend3'2"fromtransomcorner.(SeeSeriesI
sailplan.)

SeriesII:10'outboardtrackontoerailwithafter
end5'5"fromtransomcorner.10'inboardtrackwith
afterend4'2"fromtransomcorner.(SeeSeriesII
sailplan.)
NOTE:Allgenoasmustbecuttoleadwithinthetracklengthsindicatedonthesailplan.
Thispermitstheuseoftherequiredgenoasheetturningblocksandotherstandard
hardware.
15:00STEERINGSYSTEM
Wheelsteeringhasbecomeincreasinglypopularovertheyearsinlieuofatiller.
Reasonsforthispreferenceincludemorecockpitspaceandeaseofsteeringoveralong
cruise.WheelsteeringisofferedasanoptionontheSabre28and30andisstandardon
theSabre34and38.
15:01TILLERDETAIL
:Thelaminatedteaktilleristhrubolteddirectlytotherudder
post,justabovethecockpitsolebymeansofatwopart,hingedcastingwhichallows
movementtoavarietyofpositions.(RefertoI04)
15:02WHEELSTEERINGDETAIL
:Wheelsteeringusesaradialdrivewheel(orquadranton
earlySabre28's),whichisthruboltedtotherudderpostandturnedbythewheelthrough
achainandcablesystem.Astopassemblyallowsapproximately90degreesoftraveland
preventsrudderovertravelwhichcoulddamagethecableandchainassembly.Rudder