Service Manual
Revision 00 July 2012
Service
Coffee Machine
Sup 040R
Aulika
Contents Page
1. Introduction
1.1. Required documentation 1
1.2. Necessary tools and equipment 1
1.3. Materials 1
1.4. Safety cautions 1
1.5 Aulika range 2
1.6. Machine external hardware 3
1.7. Machine internal hardware 4
2. Technical data
2.1. Technical data 1
2.2. Machine behaviour and parameters 2
3. User guide
3.1. Machine warnings 1
3.2. Operator guide 2
3.3. Operation, cleaning and maintenance 7
4. Operating logic
4.1. Hydraulic Circuit 1
4.2. Emulsier valve assembly 2
4.3. Cappuccinatore assembly 2
4.4. Discharge valve 3
4.5. Coffee cycle 4
4.6. Single Microswitch 5
4.7 Temperature sensor 5
Contents Page
4.8. Water level detection (water tank) 6
4.9. Descaling request 6
4.10. Water softener 7
5. Fault nding
5.1. Test mode 1
5.2. Diagnostic mode 6
5.3 Error messages
6. Standard checks
6.1. Repairs schedule 1
6.2. Service schedule 1
6.3. Final check 2
7. Disassembly
7.1. Aesthetics 1
7.2. Coffee grinder 1
7.3. Burrs 2
7.4. Coffee grinder motor 3
7.5. Coil, microswitch and doser door 3
7.6. Doser hopper 3
7.7. Coffee boiler and steam boiler 4
7.8. Boiler pin 4
7.9. Coffee pump and steam pump 4
7.10. Turbine 5
All parts included in this document are property of Saeco International Group
All rights reserved. The company waives all liability for any damages arising out of any errors or omissions in this document and the information contained herein, and no part of
this document can be copied, used or noted down without a written authorisation or a specic contractual clause.
2012-July-08