Sanborn Mfg P1682066.MN - User Manual

Single Stage, Belt Drive, Electric Air Compressors
Compresseurs d’air électriques à un étage à entraînement par courroie
Compresores eléctricos de aire, de una sola etapa y accionamiento por correa
200-2966_ Rev D_8/10/16
200-2966
Revision D
Operator-Parts Manual
Manuel de l’opérateur - Manuel de pièces
Manual del operador - Manual de piezas
Product style and configuration may
vary.
Le style et la configuration du produit
peuvent varier.
El estilo y la configuración del
producto puede variar.
SPECIFICATION CHART / TABLEAU DES SPÉCIFICATIONS / CUADRO DE
ESPECIFICACIONES
MODEL NO.
(MODÈLE)
(MODELO)
RUNNING
H.P.
(CV)
TANK CAPACITY
GALLONS
(CAPACITÉ DU
RÉSERVOIR - LITRES)
(CAPACIDAD DEL
TANQUE - LITROS)
VOLTAGE/AMPS/
PHASE
(TENSION/AMPS/
PHASE)
(VOLTAJE/AMP/FASE)
KICK-IN
PRESSURE
(PRESSION
D’OUVERTURE)
(PRESION DE
CONEXION)
KICK-OUT
PRESSURE
(PRESSION DE
FERM.)
(PRESION DE
DESCONEXION)
P1682066.MN 1.6 20 (75,7) 120/240-15/7.5-1
105
(7,23 bar)
135
(9,30 bar)
PC1682066.MN 1.6 20 (75,7) 120/240-15/7.5-1
105
(7,23 bar)
135
(9,30 bar)
WARNING:
Read and understand all safety precautions in this manual before operating. Failure to comply with
instructions in this manual could result in personal injury, property damage, and/or voiding of your warranty. The manufacturer
WILL NOT be liable for any damage because of failure to follow these instructions.
AVERTISSEMENT:
Lire et s’assurer de bien comprendre toutes les consignes de sécurité du présent manuel avant
d’utiliser l’outil. Toute dérogation aux instructions contenues dans ce manuel peut entraîner l’annulation de la garantie, causer des
blessures et/ou des dommages matériels. Le fabricant NE SAURA être tenu responsable de dommages résultant de
l’inobservation de ces instructions.
ADVERTENCIA:
Lea y comprenda todas las precauciones de seguridad contenidas en este manual antes de utilizar
esta herramienta. El no cumplir con las instrucciones de este manual podría dar como resultado la anulación de su garantía,
lesiones personales y/o daños a la propiedad. El fabricante NO SERA responsable de cualquier daño debido a no acatar estas
instrucciones.
• Français,p.15-22
• Español,p.23-31

Summary

Air Compressor Specification Chart

Safety Guidelines and Warnings

Important Safety Instructions

Comprehensive safety advice covering fire, shock, injury, bursting, burns, and breathing hazards.

Glossary of Terms

Overview of Air Compressor

Basic Air Compressor Components

Identification of the main parts of the air compressor like motor, pump, switch, and tank.

Assembling the Compressor

Steps for unpacking, checking for damage, and preparing the compressor for initial use.

Compressor Controls

Explanation of the pressure switch, tank safety valve, pressure release valve, gauges, and regulator.

Motor Reset and Electrical Wiring

Motor Reset Switch Operation

Procedure for resetting the motor overload protector after it trips due to overheating.

Electrical Wiring and Power Requirements

Guidance on voltage, amperage, grounding, dedicated circuits, and plug configuration for safe operation.

Operating Instructions

Pump Break-In Procedure

Instructions for the initial 30-minute break-in period for the pump's internal parts.

Daily Start-Up Procedures

Steps for starting the compressor for daily use, including oil check and switch operation.

Compressor Shutdown Procedure

Steps to safely turn off the compressor, unplug, and relieve pressure.

Maintenance Procedures

Checking and Changing Pump Oil

Procedures for checking the oil level and changing the oil using the correct type.

Drive Belt Maintenance

Adjusting belt tension, aligning pulleys, and replacing drive belts for optimal performance.

Maintenance Tasks

Check Valve Maintenance

Step-by-step guide for removing, cleaning, or replacing the check valve.

Air Filter Cleaning and Replacement

Instructions on cleaning or replacing air filter elements to maintain compressor performance.

Relief Valve Check and Leak Testing

Checking the safety valve and testing for leaks in connections.

Compressor Storage

Guidelines for proper storage of the compressor to protect it from moisture and dust.

Service Interval Schedule

Troubleshooting Guide

Parts Drawing and List

Parts List Details

Pump Parts Drawing

Pump Parts List

Pressure Switch and Regulator Parts

Parts and Service Information

Sanborn Mfg P1682066.MN Specifications