Sanyo DC-DA1200V - User Manual

- 1 -
LASER BEAM SAFETY PRECAUTION
• Pick-up that emits a laser beam is used in this CD player section.
CAUTION :
THIS PRODUCT CONTAINS A LOW POWER LASER DEVICE,
TO ENSURE CONTINUED SAFETY DO NOT REMOVE ANY
COVERS OR ATTEMPT TO GAIN ACCESS TO THE INSIDE
OF THE PRODUCT.
REFER ALL SERVICING TO QUALIFIED PERSONNEL.
LASER OUTPUT .............. 0.6 mW Max. (CW)
WAVELENGTH .................. 790 nm
TAPE ADJUSTMENTS
b. Adjusting head azimuth
1. Load a test tape (VTT-738, etc. :10kHz) for
azimuth adjustment.
2. Press the PLAY button.
3. Use a cross-tip screwdriver to turn the screw for
normal azimuth adjustment so that the left and right
outputs are maximized at the same phase during
normal playback.
4. Press the STOP button.
1
2
3
4
4
MOTOR SPEED
ADJUSTMENT
c. Adjusting motor speed
1. Insert the test tape (MTT-111 or etc. 3,000 Hz).
2. Press the PLAY button.
3. Use a flat-tip screwdriver to turn the SVR to adjust so
that the frequency counter becomes 3,000 Hz.
4. Press the STOP button.
d. Replacing the motor
e. Checking the mechanism torques
• Clean the head, capstan and pinch roller before making
any measurement.
Measurement Take-up torque Back tension Tape tension
Cassette for PLAY : TW-2111A PLAY : TW-2111A Drive-power cassette
measurement F.FWD/REW : TW-2231 TW-2412
PLAY 30 ~ 70gr.cm 1.0 ~ 6.0gr.cm 80 gr or more
F.FWD/REW 55 gr or more - -
a. Replacing the head
1. After replacement, demagnetize the heads by using
a degausser.
2. Be sure to clean the heads before attempting to make
any adjustments.
3. Be sure both channels (1 and 2) are the same level.
(Using a dual-channels oscilloscope).
4. All wiring should be returned to the original position
after work is completed.
CAUTION – INVISIBLE LASER RADIATION WHEN OPEN AND
INTERLOCKS DEFEATED. AVOID EXPOSURE TO BEAM.
ADVARSEL – USYNLIG LASER STRÅLING VED ÅBNING, NÅR
SIKKERHEDSAFBRYDERE ER UDE AF FUNKTION, UNDGÅ UDS ÆTTELSE
FOR STRÅLING.
VARNING – OSYNLIG LASER STRÅLNING NÄR DENNA DEL ÄR ÖPPNAD
OCH SPÄRR ÄR URKOPPLAD. STRÅLEN ÄR FARLIG.
VORSICHT – UNSICHTBARE LASERSTRAHLUNG TRITT AUS, WENN
DECKEL GEÖFFNET UND WENN SICHERHEITSVERRIEGELUNG
ÜBERBRÜCKT IST. NICHT, DEM STRAHL AUSSETZEN.
VARO – AVATTAESSA JA SUOJALUKITUS OHITETTAESSA OLET ALTTIINA
NÄKYMÄTTÖMÄLLE LASERSÄTEILYLLE. ÄLÄ KATSO SÄ
TEESEEN.
R / P HEAD
RED
WHITE
YELLOW EARTH

Summary

Laser Beam Safety Precautions

Laser Hazard Warning

Product contains a low power laser device. Do not remove covers.

Laser Output and Wavelength

Specifies laser output power and wavelength.

Tape Adjustments

Tape Head Replacement and Azimuth Adjustment

Procedures for replacing tape heads and adjusting azimuth.

Motor Speed and Mechanism Torque Adjustments

Steps for adjusting motor speed and checking mechanism torques.

Tuner Adjustments

FM Tuning Adjustments

Adjustments for FM signal reception and tuning.

AM Tuning Adjustments

Adjustments for AM signal reception and tuning.

CD Pick-up Maintenance

Optical Lens Cleaning Procedure

Procedure for cleaning the CD pick-up optical lens.

Parts List Overview

Product Safety Notice

Precautions for servicing and component identification.

Packing and Accessories

List of packing and accessory parts.

Cabinet and Chassis Parts

List of cabinet and chassis parts.

Fixing Parts

List of fixing parts.

Electrical Parts

List of electrical parts.

Sanyo DC-DA1200V Specifications

General

Frequency response	40Hz - 20kHz
Input sensitivity	500mV
CD Player	Yes
USB Playback	Yes
AUX Input	Yes
Remote Control	Yes
Tuning range	FM
Output	Speaker, Headphone