Home
SciCan
Washer
HYDRIM L110 G4 Series
SciCan HYDRIM L110 G4 Series Service Manual
4
of 1
of 1 rating
74 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
HYDR
IM
L110w G4
INSTRUMENT WASHER
HYDR
IM
L110w G4 Service Manual 96-113788 Rev. 1.0 Copyright 2013 SciCan Ltd. All rights reserved
t
4FSWJDF
.BOVBM
t
.BOVFM
EF
MVUJMJTBUFVS
t
2
Table of Contents
Table of Contents
2
Introduction
4
Overview
4
Unit at a Glance
5
Front and Rear of Unit
5
Left and Right of Unit
6
Specifications
7
Safety Information
8
Safe Operation
8
Safe Servicing
8
Tools and Hardware
9
Disconnecting the Unit
10
Shipping Instructions
11
Installation
12
Setting Water Softener
14
Setting the Language
15
Setting the Country
15
Setting the Time
15
Setting the Date
16
Assigning the Unit Identifier Number
16
Adjusting the Screensaver Delay
17
Adjusting Temperature Display
17
Turning the Button Sound on or off
17
Adjusting the Button Beep Volume
17
Adjusting the Salt Regeneration
18
Adjusting the Screen Contrast
18
Changing the Touchscreen Display Themes
18
Creating a User Name
19
Creating a User PIN
19
Setting up Process Enforced Usage
20
Connecting to a Network
20
Connecting to a Wireless Network
21
Routine Procedures and Maintenance
22
Replacing the Cleaning Solution
22
Refilling the Water Softener
23
Filter and Wash Arm Maintenance
24
Cleaning the Chamber
25
Draining the Unit for Service or Shipping
25
Upgrading the Firmware and Themes
25
Using a USB Drive with the Software
26
Loaded Onto It
26
Upgrading Another HYDRIM G4 Unit with the same USB Drive
26
Using the HYDRIM Remote Access Function
27
Annual Service Requirements
28
Diagnostics and Troubleshooting
30
Using the Service Menu
30
Using the Setup Menu
31
Using the User Menu
32
Using Software Tools for Diagnostics
33
Debug Screen
33
I/O Status Screen
34
Troubleshooting Cycle Faults
35
Removing and Replacing Panels
38
Removing and Reinstalling the Top Panel
39
Removing and Reinstalling the Side and Rear Panels
39
Front Components
40
Removing and Reinstalling the Kickplate
41
Opening the Door with the Manual Door Release
41
Removing and Reinstalling the Sump Temperature Sensor
42
Removing and Reinstalling the Chemical Dosing Valve
43
Removing and Reinstalling the Chemical Reservoirs
44
Door Components
45
Removing and Reinstalling the Chamber Seal
46
Removing and Reinstalling the Lower Door Seal
47
Removing and Reinstalling the Door
48
Removing and Reinstalling the Lower Door D-Seal
49
Removing and Reinstalling the Door Latch
49
Removing and Reinstalling the Door Springs
50
Right Side Components
51
Removing and Reinstalling the LCD Touchscreen and LCD Controller
52
Removing and Reinstalling the I/O Board
54
Removing and Reinstalling the Power Supply
55
Removing and Reinstalling the Dosing Pump
56
Removing and Reinstalling the Chamber Level/Overflow Switch
57
Removing and Reinstalling the Drain Pump and Exhaust Assembly
58
Removing and Reinstalling the Dryer Motor
59
Removing and Reinstalling the Power Switch
60
Removing and Reinstalling the USB Port
60
Left Side Components
61
Removing and Reinstalling the Sump Water Heater
62
Removing and Reinstalling the Recirculation Pump
63
Rear Components
64
Removing and Replacing the Ethernet and RS232 Ports
65
Removing and Reinstalling the Air Chamber Pressure Switch
65
Removing and Reinstalling the Water Softener System
66
Removing and Reinstalling the Air Break
67
Removing and Reinstalling the Water Inlet Valves
68
Removing and Reinstalling the Fuses and Fuse Holders
69
Removing and Reinstalling the AC Power Inlet / EMI Filter
69
Spare Parts & Accessories
70
Appendices
73
Appendix A HYDRIM L110W G4 Electrical Schematic
73
Appendix B HYDRIM L110W G4 Flow Diagram
74
Other manuals for SciCan HYDRIM L110 G4 Series
Operator's Manual
41 pages
Quick Reference Guide
2 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the SciCan HYDRIM L110 G4 Series and is the answer not in the manual?
Ask a question
SciCan HYDRIM L110 G4 Series Specifications
General
Model
HYDRIM L110 G4 Series
Type
Washer
Manufacturer
SciCan
Category
Washer
Detergent Dispensing
Automatic
Connectivity
USB
Related product manuals
SciCan HYDRIM L110w G4
74 pages
SciCan HYDRIM G4
9 pages
SciCan HYDRIM M2 G4
42 pages
SciCan HYDRIM L110w
39 pages
SciCan HYDRIM M2
29 pages
SciCan hydrim c51w
59 pages
Need help?
General
To Next Page
