INTRODUCTION
This product manual contains the information
needed for the setup, installation, initial start up,
sanitation and maintenance of this ice machine.
Keep it for future reference.
There are 2 models covered in this manual:
• CME1356, having 5 evaporators
• CME1656, having 6 evaporators
Be certain that the information applies to the model
in question. If no model is listed, the information
applies to all models.
This manual is organized in the same way as the
expected use of the machine, it begins with
specifications, goes thru unpacking and setup,
shows where everything is; continues with initial
start up, then describes how it works. After that is
the sanitation section, followed by service diagnosis
and repair.
TABLE OF CONTENTS
Specifications .................PAGE2
Air Cooled Layout ...............PAGE3
Water Cooled Layout .............PAGE4
Pre-Installation .................PAGE5
Location & Assembly .............PAGE6
Stacking ....................PAGE7
Stacking ....................PAGE8
Bin Control: Installation ............PAGE9
Bin Control ...................PAGE10
Plumbing ....................PAGE11
Electrical ....................PAGE12
After Utility Connections ............PAGE13
Component Description and Function .....PAGE14
System Controller ...............PAGE15
Initial Start Up .................PAGE16
Adjustments ..................PAGE17
Adjustments ..................PAGE18
How To Operate The System Controller . . . PAGE 19
How The Electronic Cuber Works .......PAGE20
How The Electronic Cuber Works .......PAGE21
Technicians Only: Freeze Cycle Operational
Sequence ...................PAGE22
Technicians Only: Harvest Cycle Operational
Sequence ...................PAGE23
Sanitation and Cleaning ............PAGE24
Additional Maintenance ............PAGE25
Additional Maintenance: Water Distributors . . PAGE 26
Additional Maintenance: Inlet Water Valve
Screen .....................PAGE27
Additional Maintenance: Ice Sensors, Condenser
........................PAGE28
Service Diagnosis: Controller Diagnostic Light
Analysis ....................PAGE29
Service Diagnosis ...............PAGE30
Service Diagnosis: Components .......PAGE31
PTCR .....................PAGE32
Operational Characteristics: CME1356 ....PAGE33
Operational Characteristics: CME1656 ....PAGE34
Removal and Replacement ..........PAGE36
Removal and Replacement: System Controller PAGE 37
Removal and Replacement: Water Level Sensor
........................PAGE37
Removal and Replacement: Fan Blade and/or Fan
Motor .....................PAGE38
Access Valves .................PAGE39
Liquid Charging ................PAGE40
Before Calling for Service ...........PAGE41
Parts Lists and Wiring Diagrams are Located in the Center of this Manual
CME1356 and CME1656
May 2000
Page 1
To Next Page
Need help?
General
