Sealey GI2300 - Page 3

devices that require a large starting current. This is not a malfunction.
4.3.4. AC pilot light (green)
 TheACpilotlightg.3.(2)comesonwhentheenginestartsandproducespower.
4.4. DC Protector
4.4.1. TheDCprotectorturnsto“OFF”g.4.(2)automaticallywhenelectricdevicebeing
connected to the generator is operating at a higher current than the max stated in
 specications.
4.4.2. To turn the power on press the button to the “ON” (1) position.
N.B. Reduce the load before restarting.
4.5. Economy control switch (ECS) g.5
4.5.1. “ON” (1)
When the ECS switch is turned to “ON” the economy control unit controls the engine speed according to the connected load. The
results are better fuel consumption and less noise.
4.5.2. “OFF” (2)
When the ECS switch is turned to “OFF” the engine runs at the rated speed (3600r/min) regardless of whether a load is connected or
not.
4.5.3. The ECS must be turned to “OFF” when using electric devices that require a larger starting current.
4.6. Earth terminal g.4
4.6.1. Earthterminalg.5.(1)connectstheearthlinetopreventelectricshock.
N.B If the device is earthed the generator must be earthed.
4.7. FUEL
4.7.1. Do Notoverllthefueltank,otherwiseitmay
 overowwhenthefuelwarmsupandexpands.
4.7.2. Afterllingensuretankcapistightenedsecurely.
4.7.3. Wipe off any fuel that has been spilled.
4.7.4. Use only unleaded petrol.
4.7.5. Removethefueltankcapg.6.
4.7.6. Pourinfueluptotheredlineg.7.(1)
4.7.7. Fuellevelg.8.(2)
4.8. Engine oil
N.B. The generator has been transported without engine oil. Do not start the
 engineuntillledwithsufcientengineoil.
4.8.1. Place the generator on a level surface.
4.8.2. Remove the oil gauge.
4.8.3. Fillthegeneratorwiththeamountofengineoilspecied.
4.8.4. Replaceoilgaugeg.9.
4.8.5. RecommendedengineoilSAESJ15W-40.
4.8.6. Engineoilcapacity0.45L.
4.9. Standard atmospheric conditions
Ambient temperature 25
o
C
Barometric pressure 100kPa
Relative humidity 30%
The output of the generator will vary dependant on the deviation from the standard conditions.
g.4
g.5
g.6
g.7
g.8
g.9
GI2300,GI3500Issue2(g1)19/04/18
Original Language Version
© Jack Sealey Limited