EasyManua.ls Logo

Sears Craftsman 944.602660 - User Manual

Sears Craftsman 944.602660
60 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
24.0 HP - 724cc
*
ELECTRIC START
42" MOWER
AUTOMATIC TRANSMISSION
LAWN TRACTOR
Important:
Read and fol low
all Safety Rules
and In struc tions
Be fore Op er at ing
This Equip ment
MODEL NO.
944.602660
OPERATOR’S
MANUAL
• Assembly
• Operation
• Maintenance
• Service and Adjustments
Sears Canada, Inc., Toronto, Ontario M5B 2B8
*As rated by the engine manufacturer
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.
580399224
02.17.12 BD
PRINTED IN THE U.S.A.

Questions and Answers

  • C
    Charles NavarroAug 19, 2025
    Why Sears Craftsman 944.602660 Lawn Mower will not start?
    • K
      Karla ThompsonAug 19, 2025
      If your Sears Lawn Mower won't start, several factors could be the cause. It could be due to: * being out of fuel (fill the fuel tank), * improper choking (consult the Operation section for starting instructions), * a flooded engine (wait a few minutes before restarting), * a bad spark plug (replace it), * a dirty air filter (clean or replace it), * a dirty fuel filter (replace it), * water in the fuel (empty the tank and carburetor, refill with fresh gasoline, and replace the fuel filter), * loose or damaged wiring (check all wiring). If these steps don't resolve the issue, the carburetor might need adjustment, or the engine valves may be out of adjustment.
  • K
    Kristen KempAug 21, 2025
    How to fix Sears Craftsman 944.602660 that is hard to start?
    • S
      smithvictoriaAug 21, 2025
      If your Sears Lawn Mower is hard to start, consider these possible causes: * A dirty air filter (clean or replace it). * A bad spark plug (replace it). * A weak or dead battery (recharge or replace it). * A dirty fuel filter (replace it). * Stale or dirty fuel (empty the fuel tank and refill it with fresh, clean gas). * Loose or damaged wiring (check all wiring).
  • S
    Sandra JacksonAug 23, 2025
    Why Sears Craftsman 944.602660 engine "back-fires” when turning engine “OFF”?
    • A
      aguilarjamesAug 23, 2025
      If your Sears Lawn Mower engine backfires when turning it off, make sure the engine throttle control is set between half and full speed (fast) position before stopping the engine.
  • J
    Jacob McbrideAug 28, 2025
    What to do if Sears Craftsman 944.602660 engine will not turn over?
    • R
      Robert HuertaAug 28, 2025
      If the engine of your Sears Lawn Mower won't turn over, check the following: * Ensure the brake pedal is depressed. * Disengage the attachment clutch. * Check for a weak or dead battery; recharge or replace if necessary. * Replace the fuse if it's blown. * Clean corroded battery terminals. * Inspect all wiring for looseness or damage. * Check or replace the ignition switch if faulty. * Check or replace the solenoid or starter if faulty.
  • H
    Henry RomeroAug 29, 2025
    What to do if Sears Craftsman 944.602660 Lawn Mower engine clicks but will not start?
    • J
      Justin SimmonsAug 30, 2025
      If your Sears Lawn Mower engine clicks but doesn't start, the issue might be: * A weak or dead battery (recharge or replace the battery). * Corroded battery terminals (clean the battery terminals). * Loose or damaged wiring (check all wiring). * A faulty solenoid or starter (check/replace the solenoid or starter).
  • M
    michelle09Sep 1, 2025
    Why Sears Lawn Mower has excessive vibration?
    • H
      harrisrichardSep 1, 2025
      Excessive vibration in your Sears Lawn Mower could be due to: * A worn, bent, or loose blade (replace the blade and tighten the blade bolt). * A bent blade mandrel (replace the blade mandrel). * Loose or damaged parts (tighten loose parts and replace damaged parts).
  • J
    Jesse WilliamsSep 5, 2025
    Why Sears Craftsman 944.602660 has poor cut that is uneven?
    • D
      David JacobsSep 5, 2025
      An uneven cut with your Sears Lawn Mower can be caused by: * A worn, bent, or loose blade (replace the blade and tighten the blade bolt). * The mower deck not being level (level the mower deck). * Buildup of grass, leaves, or trash under the mower (clean the underside of the mower housing). * A bent blade mandrel (replace the blade mandrel). * Clogged mower deck vent holes (clean around mandrels to open vent holes).
  • Q
    qspearsSep 7, 2025
    What to do if Sears Lawn Mower blades will not rotate?
    • B
      Benjamin TaylorSep 7, 2025
      If the blades of your Sears Lawn Mower won't rotate, it could be due to: * An obstruction in the clutch mechanism (remove the obstruction). * A worn or damaged mower drive belt (replace the mower drive belt). * A frozen idler pulley (replace the idler pulley). * A frozen blade mandrel (replace the blade mandrel).
  • U
    umerrittSep 9, 2025
    Why Sears Craftsman 944.602660 headlight(s) not working (if so equipped)?
    • J
      jamesyoungSep 9, 2025
      If the headlights on your Sears Lawn Mower aren't working, check these: * Ensure the switch is turned “ON”. * Replace any burned-out bulbs or lamps. * Check or replace the light switch if it's faulty. * Inspect the wiring and connections for looseness or damage. * Replace the fuse if it's blown.
  • T
    Tracy CollierSep 12, 2025
    Why Sears Lawn Mower battery will not charge?
    • R
      Ronald MckeeSep 12, 2025
      If your Sears Lawn Mower battery won't charge, consider these possibilities: * Bad battery cells (replace the battery). * Poor cable connections (check and clean all connections). * Faulty regulator, if equipped (replace the regulator). * Faulty alternator (replace the alternator).

Summary

GENERAL SAFETY PRACTICES

GENERAL OPERATION

Basic safe operating procedures for the tractor.

SLOPE OPERATION

Safe practices for operating on inclines and slopes.

CHILDREN SAFETY

Safety precautions regarding children and the tractor.

GASOLINE HANDLING SAFETY

Important safety measures for handling gasoline.

TRACTOR SPECIFICATIONS

TECHNICAL DATA

Lists key technical details like capacity, oil type, spark plug.

WARRANTY AND RESPONSIBILITIES

WARRANTY OBLIGATIONS

Outlines customer duties for maintaining warranty validity.

ASSEMBLY

TRACTOR UNPACKING AND SETUP

Steps for unpacking, checking battery, adjusting seat, and removing from skid.

PRE-OPERATION CHECKLIST

Checklist of items to review before operating the tractor for the first time.

OPERATION

UNDERSTANDING TRACTOR SYMBOLS AND HAZARDS

Explains symbols and defines hazard alerts.

KNOW YOUR TRACTOR CONTROLS

Familiarization with tractor controls and their locations.

BASIC OPERATION PROCEDURES

Setting brake, stopping, moving forward/backward.

MOWER AND CRUISE CONTROL ADJUSTMENTS

Adjusting mower height, gauge wheels, and using cruise control.

REVERSE OPERATION AND SLOPE SAFETY

Using ROS and safety guidelines for operating on slopes.

ENGINE STARTING AND TRANSMISSION WARM-UP

Procedures for starting the engine and warming up the transmission.

TRANSMISSION PURGING AND MOWING TIPS

Procedure to purge transmission and advice for effective mowing.

MAINTENANCE

MAINTENANCE SCHEDULE AND GUIDELINES

Schedule of tasks and general advice for maintaining the tractor.

KEY COMPONENT MAINTENANCE CHECKS

Checks for brakes, tires, safety systems, blades, and battery.

ENGINE MAINTENANCE

Maintaining engine oil, filters, and spark plugs.

FUEL FILTER AND DECK WASHING

Replacing fuel filter and using the deck washout port.

SERVICE AND ADJUSTMENTS

MOWER REMOVAL AND INSTALLATION

Detailed steps for removing and installing the mower deck.

CHASSIS, LINKAGE, AND BELT INSTALLATION

Connecting mower components and installing drive belts.

LEVELING THE MOWER DECK

Procedures for adjusting the mower deck for levelness.

REPLACING DRIVE BELTS AND CHECKING BRAKES

Steps for belt replacement and brake system verification.

WHEEL REMOVAL AND JUMP-STARTING

Instructions for wheel removal and jump-starting a weak battery.

BATTERY AND ENGINE ADJUSTMENTS

Replacing battery and adjusting engine controls.

STORAGE

TRACTOR, ENGINE, AND BATTERY STORAGE PREPARATION

Procedures for preparing the tractor for long-term storage.

TROUBLESHOOTING

STARTING AND POWER ISSUES

Solutions for engine starting problems and loss of power.

OPERATION AND VIBRATION PROBLEMS

Troubleshooting for engine not turning over, excessive vibration.

CUTTING, DRIVE, AND ELECTRICAL PROBLEMS

Resolving issues with mower cut, discharge, drive, and electrical systems.

SAFE SLOPE MEASUREMENT GUIDE

MEASURING SLOPE ANGLES FOR SAFETY

Method for determining slope angles to ensure safe operation.

WARRANTY INFORMATION

WARRANTY TERMS AND RESPONSIBILITIES

Overview of warranty coverage, limitations, and customer obligations.

SERVICE NOTES

CONTACT AND SUPPORT INFORMATION

SEARS SERVICE AND SUPPORT CONTACTS

Contact details for home repair, parts, and maintenance agreements.

Sears Craftsman 944.602660 Specifications

General IconGeneral
BrandSears
ModelCraftsman 944.602660
CategoryLawn Mower
LanguageEnglish

Related product manuals