Page 24
Page 24
COMPONENT DESCRIPTION
1. Front Console Panel
Equipped with five LED plus a push button that
when glow or blink are monitoring:
LED Nr. 1
Electrical power supply.
LED Nr. 2
Operation.
LED Nr. 3
Bin full./Washing.
LED Nr. 4
Alarm.
2. P.C. Board
Located in the control box, this board is the brain
of the system as it governs the ice machine
cyclematic through sensors, relays and switch.
It consists of two separated printed circuits one at
high and the other at low voltage integrated with
a fuse, of four connectors for the sensors/switches
(condenser sensor - BLACK -, magnetic switch
- GREEN - ice thickness sensor - RED - water
level sensor - BLUE), of two jumpers (one J1 for
factory use only - and the second J2 for the
selection between one water fill up or continuous
water fill up), of one outlet connector (front LED
display - black) one serial port connector (black)
and of four plug in terminals for input and output
power.
With J2 closed the P.C. Board is set up for water
fill up at beginning freeze mode. When J2 is open
the PC Board is set up for continuous water filling
mode.
The P.C. Board is equipped by an electronic
safety timer that turns-on automatically the unit
to defrost cycle when freezing cycle is longer
then 30 or 40 minutes and trips-off completely
unit when defrost cycle is longer then 3,5 minutes
(4th Red LED ON).
A trimmer, located close to the transformer, can
change the current received back from the Ice
Tickness Sensor according to the Electrical
Conductivity of the water.
3. Compressor Contactor
Located in the control box, the compressor
contactor functions to carry the compressor line
current. The contactor is wired to receive power
from the P.C. Board.
LED Nr. 5
Alarm high pressure.
BUTTON B
Reset/Washing.
SV SERIES
PC BOARD
2J
1J
RESNEDNOC
RESNEDNOC
ROSNES
ROSNES
CITENGAM
CITENGAM
HCTIWS
HCTIWS
SSENKCIHTECI
SSENKCIHTECI
ROSNES
ROSNES
YALPSID
YALPSID
ROTCENNOC
ROTCENNOC
ESUF
ESUF
NIREWOP
NIREWOP
YTEFASDNA
YTEFASDNA
ERUSSERP
ERUSSERP
SLORTNOC
SLORTNOC
NAF
NAF
SROTOM
SROTOM
PMUPRETAW
PMUPRETAW
RETAW,SAGTOH,ROSSERPMOC
RETAW,SAGTOH,ROSSERPMOC
SEVLAVNIARDDNATELNI
SEVLAVNIARDDNATELNI
RETAW
RETAW
YTIVITISNES
YTIVITISNES
TNEMTSUJDA
TNEMTSUJDA
TUOPMUJ-.O.N
TUOPMUJ-.O.N
SUOUNITNOC
SUOUNITNOC
GNILLIFRETAW
GNILLIFRETAW
NIPMUJ-.C.N
NIPMUJ-.C.N
PULLIFRETAW
PULLIFRETAW
GNINNIGEB
GNINNIGEB
YLNOEZEERF
YLNOEZEERF
-
-
+
+
LEVELRETAW
LEVELRETAW
ROSNES
ROSNES
LAIRES
LAIRES
ROTCENNOC
ROTCENNOC
YROTCAFROF
YROTCAFROF
YLNOESU
YLNOESU
To Next Page
Loading...
