Ski-Doo MX-Z - Air Shock Absorber Adjustment; Troubleshooting Chart and Deep Snow; Front Suspension Wandering Issues; Snowmobile Instability Issues

163 pages

Save Page as PDF

To Next Page

To Previous Page

TOO HARD OF ADJUSTMENT

1. Steering hard to turn

1. Decrease spring preload

A32F0EA

A03F2JA

Mmo2003-003a.book Page 95 Tuesday, March 19, 2002 2:22 PM

Main Page

Default Chapter2
- Default Chapter2
  - Safety Warning2
  - Table of Contents6
- Safety Measures9
List of Hot Parts10
List of Moving Parts10
Bombardier Limited Warranty North America: 2003 Ski-Doo Snowmobiles11
Bombardier Limited Warranty International: 2003 Ski-Doo Snowmobiles14
Frequently Asked Questions17
Authorized Ski-Doo Dealers19
How to Identify Your Snowmobile19
- Vehicle Description Decal19
- Serial Numbers20
On-Vehicle Important Instructions22
Controls/Instruments/Equipment30
- Throttle Lever33
- Brake Lever33
- Parking Brake Locking Lever or Button33
- Brake/Parking Brake Pilot Lamp (Red)35
- Low Injection Oil Level (Red)36
- Handlebar36
- Adjustable Handlebar37
- Holding Strap37
- RER Button38
- Start/Rer Button40
Ignition Switch43
- Tether Cut-Out Switch44
- DESS Pilot Lamp (Red)47
- DESS/RER Pilot Lamp (Red)47
- RER Pilot Lamp (Red)47
- Engine Cut-Out Switch48
- Headlamp Dimmer Switch49
- High Beam Pilot Lamp (Blue)49
- Rewind Starter Handle49
- Choke Lever50
- Speedometer51
- Mode Button52
- Odometer52
- Trip Meter52
- Resetable Hourmeter53
- Trip Meter Reset Button53
- Engine Overheat Warning Lamp (Red)54
- Tachometer54
- Temperature Gauge54
- Fuel Tank Cap/Gauge55
- Electric Fuel Level Gauge56
- Heated Grip Switch56
- Heated Throttle Lever Switch57
- Electric Visor Jack Connector59
- 12-Volt Power Outlet60
- Air Suspension Switch61
- Air Suspension Compressor Pilot Lamp62
- Air Suspension Gauge62
- Hood Latches62
- Adjustable Mirrors63
- Adjustable Toeholds63
- Heated Carburetor Valve64
- Adjustable Backrest65
- Seat Strap67
- Rear Passenger Heated Grip Switch68
- Adjustable Rear Grab Handles69
- Hood Grills70
- Rear Rack71
- Storage Compartment71
- Tool Bag72
- Fuses73
- Spare Spark Plug Holder75
- Spare Drive Belt Holder76
- Convertible Ski Stance77
- Front Grab Handles/Front Bumper77
- Adjustable Suspensions78
- General79
- Guidelines to Adjust Suspension80
- In Deep Snow99
Troubleshooting Chart99
- Fuel and Oil100
- Recommended Fuel100
- Recommended Oil101
Operating Instructions102
- 10-Hour Inspection102
- Belt102
Break-In Period102
- Cold Weather Carburetion Modifications102
- Engine102
- Pre-Operation Check103
- Pre-Operation Check List105
- Operating Instructions106
- Principle of Operation106
- Starting the Engine107
- Emergency Starting109
- Shutting off the Engine112
Vehicle Warm-Up112
- Engine Overheating113
Post-Operation Care113
- Riding at High Altitudes113
Special Operations113
- Fuel Flooded Engine114
- Rear Suspension Slider Shoe Sticking114
Periodic Maintenance Chart115
- Brake System117
Fluid Levels117
- Chaincase Oil Level118
- Oil Injection System119
- Cooling System120
Maintenance121
- Vehicle Cleaning and Protection121
- Belt Guard Removal and Installation122
- Drive Belt Removal/Installation124
- Drive Chain Tension129
- TRA Drive Pulley Adjustment129
- Brake Adjustment132
- Brake Condition132
- Drive Belt Condition132
- Rear Suspension Condition133
- Suspension Stopper Strap Condition133
- Track Condition133
- Track Tension and Alignment133
- Steering and Front Suspension Mechanism137
- Air Filter Cleaning138
- Exhaust System138
- Wear and Condition of Skis and Runners138
- Bulb Replacement141
- Headlight Beam Aiming141
- Battery Electrolyte145
- Preseason Preparation146
- Storage146
- Storage and Preseason Preparation146
- Towing the Vehicle146
- Transporting the Vehicle146
- Troubleshooting147
- Specifications150
- Change of Address or Ownership160
- Privacy Obligations/Disclaimer160

Ski-Doo MX-Z - Air Shock Absorber Adjustment; Troubleshooting Chart and Deep Snow; Front Suspension Wandering Issues; Snowmobile Instability Issues

Table of Contents

Related product manuals