SmartPool NC71AU - NC71 AU Test and Results Chart

To Previous Page

INTHISCHART

NC71AUTESTANDRESULTSCHART

COMPONENT WORKINGRANGE SYMPTOM(S)/RESULT(S)OFDEFECTIVECOMPONEN

ADDITIONALINFORMATION

POWERSUPPLY 29‐32Vdc CLEANERWILLBEDEADINWATE

CABLE 26‐29Vdc CLEANERWILLBEDEADINWATER MAKESURETOTESTTHECABLEWHILEPUMPMOTORISRUNNING

PUMPMOTORWILLTURN1/4ROTATIONATATIME VOLTAGEDROPISNOTVISIBLEBECAUSEPUMPWILLNOTRUNLONGENOUGH

IFVOLTAGEDROPTHROUGHCABLEISGREATERTHEN4Vdc PUMPMOTORWILLRUNBUTDRIVEMOTORWILLNOT

THENTHECABLEISSUSPECT PUMPMOTORWILLRUNBUTONLYONESIDEOFDRIVEMOTORWILLTURN CLEANERWILLSPININCIRCLESDURINGOPERATION

CLEANERWILLRUNSLUGGISHLY/MAYNOTCLIMB

CLEANERWILLFLOATORRIDEONBACKWHEELS

PUMPMOTOR 26‐29Vdc CLEANERWILLBEDEADINWATER

GENERALLYIFTHEPUMPMOTORRUNSTHENTHEPUMP PUMPMOTORWILLRUNBUTDRIVEMOTORWILLNOT PUMPMOTORISALSOTHEPROCESSOROFTHECLEANER

MOTORISOK(DOESNOTMEANPROCESSORISOK) CLEANERWILLNOTRUNAFULLCYCLE

PUMPMOTORCONTROLSTHECYCLETIMEOFTHECLEANE

DRIVEMOTOR USETESTCABLETOCHECKCOMPONENTOPERATION PUMPMOTORWILLRUNBUTDRIVEMOTORWILLNOT

PUMPMOTORWILLRUNBUTONLYONESIDEOFDRIVEMOTORWILLTURN

CLEANERWILLSPININCIRCLES

CLEANERWILLSTARTBUTSHUTDOWNCOMPLETELYWHENDRIVEMOTORTURNSON SIGNOFPOSSIBLEWATERENTRY

TRACKS 0.09‐0.22AMPS CLEANERWILLRUNSLUGGISHLY/MAYNOTCLIMB THISISTYPICALLYSEENDIRECTLYOUTOFTHEBOX

CLEANERWILLSPININCIRCLES BESURETOELIMINATEOTHERPOSSIBILITIES(CABLE/DRIVEMOTOR)

PUMPMOTORWILLRUNBUTDRIVEMOTORWILLNOT BESURETOELIMINATEOTHERPOSSIBILITIES(CABLE/DRIVEMOTOR)

BEARINGMAYBESEIZEDINDRIVEPULLEY(S) SMALLSANDLIKEMATERIALWILLBEPRESENTINBEARINGS

DRIVEMOTORWILLSTOPROTATINGWHELITTLER

ESISTANCEISAPPLIED THISMAYALSOBEADEFECTIVEDRIVEMOTOR(REMOVETRACKANDTESTDRIVE

)

*THESERESULTSANDSYMPTOMSAREISSUESTHATARETYPICALLYFOUNDTOCAUSEFAULTWITHTHECLEANERANDITSCOMPONENTS.NOTALLFAULTSMAYBECOVERED