To Next Page
E
Elaine AllenSep 12, 2025
What if fuel outlet cock closed in Sole Diesel MINI 33 Engine?
- MMark MichaelSep 12, 2025
A closed fuel outlet cock in a Sole Diesel Engine can be caused by issues related to the fuel system (C9).
What if fuel outlet cock closed in Sole Diesel MINI 33 Engine?
A closed fuel outlet cock in a Sole Diesel Engine can be caused by issues related to the fuel system (C9).
What to do if Sole Diesel Engine starts then stops?
If your Sole Diesel Engine starts and then stops, check the fuel pump inlet and replace the fuel filter if it's clogged. Bleed the fuel system to remove any air. Ensure the fuel outlet cock is open and restore the coolant to the normal operating level if it's low. Check the key switch pin connections, especially those giving a signal to the stop solenoid and fuel pump.
How to reduce high fuel consumption in a Sole Diesel Engine?
To address high fuel consumption in your Sole Diesel Engine, check the engine compression. Reduce the electrical load if there's an overload. Adjust the fuel injection timing. Replace the air filter. Replace the thermostat and check the coolant state if the thermostat is blocked in the open position.
How to troubleshoot a Sole Diesel MINI 33 Engine that fails to start?
If your Sole Diesel Engine fails to start, begin by checking the key switch pin connections for voltage and the electronic board voltage to the micro relay. Inspect and replace the controller fuse if blown, and troubleshoot the controller if the fuse blows again. Ensure the battery is charged or replace if dead. Verify battery connections are correct, clean, and tight. Examine the cranking relay and stop solenoid, replacing if faulty. Replace the starter motor if inoperative. Check the engine compression and oil viscosity against technical specifications. Check the fuel pump inlet, fuel lines, and replace the fuel filter if clogged. Bleed the fuel system to remove air. Clean, test, or replace faulty fuel injectors, and adjust fuel injection timing if needed. Ensure the fuel tank isn't empt...
What causes faulty oil pump in Sole Diesel MINI 33 Engine?
A faulty oil pump in a Sole Diesel Engine can be caused by issues related to the lubrication system (L1).
What causes faulty oil pressure gauge or switch in Sole Diesel Engine?
A faulty oil pressure gauge or switch in a Sole Diesel Engine can be caused by issues related to the lubrication system (L8).
What causes a faulty or clogged fuel pump in Sole Diesel Engine?
A faulty or clogged fuel pump in a Sole Diesel Engine can be caused by issues related to the fuel system (C1).
What causes obstructed fuel lines in Sole Diesel Engine?
Obstructed fuel lines in a Sole Diesel Engine can be caused by issues related to the fuel system (C2).
What causes oil suction lines clogged or unions loose in Sole Diesel MINI 33 Engine?
Clogged or loose oil suction lines in a Sole Diesel Engine can be caused by issues related to the lubrication system (L9).
What causes black smoke from a Sole Diesel Engine?
Black smoke from a Sole Diesel Engine can be attributed to problems with the fuel system (C3, C6, C7), mixture system (M1, M4), or the regulator system (R1, R2).
General introduction and welcome message from Solé Diesel.
List of common abbreviations used in the manual.
Defines the units of measurement and their conversions used in the manual.
Explanation of warning, caution, and notice symbols used in the manual.
Safety warnings for handling fuel and servicing the fuel system.
Hazards and safety warnings related to carbon monoxide and batteries.
Precautions for moving parts and general safety recommendations.
Details of limited and extended warranty coverage periods.
Conditions and situations not covered by the warranty.
Information on contacting for warranty claims and required documentation.
Details on how to identify the engine using nameplate and serial number.
Diagrams and list identifying key engine components.
Instructions for inspecting the engine upon delivery for damage or missing parts.
Guidelines for lifting and transporting the engine safely.
Instructions for transporting the engine using lifting eyebolts.
Recommendations for engine storage and precautions for long periods of idleness.
Permitted angular operation limits for engine installation.
Step-by-step guide for installing the engine, including connections.
Overview of different SVT control panel models and their features.
Detailed description of the functions of SVT panel components and indicators.
Instructions for tachometer calibration and replacing light bulbs.
Essential checks before starting the engine for correct operation.
Procedure for starting the engine using the key switch.
Checks after start-up, stopping procedure, and low temperature ops.
Steps to maintain the engine during long periods of inactivity.
Procedures to follow to restart the engine after winter lay-up.
General safety precautions and recommendations for maintenance.
Table outlining inspection items and their recommended maintenance intervals.
Information on spare parts packs and general maintenance tasks.
Procedure for oil filter change and oil level check.
Procedures for fuel level check, tank cleaning, filter purge/change, and pump inspection.
Procedures for coolant checks/changes and seawater filter inspection.
Procedures for air filter and exhaust system inspection.
Maintenance tasks for the SVT panel, battery, and glow plugs.
Procedures for handling faults during and outside the warranty period.
Troubleshooting table for engine failure to start.
Troubleshooting table for engine black and blue smoke issues.
Troubleshooting tables for engine overheating and oil pressure issues.
Troubleshooting for low power, high consumption, and battery issues.
General, lubrication, and fuel system specifications for MINI-17 and MINI-29.
General, lubrication, and fuel system specifications for MINI-33, MINI-44, MINI-55.
Cooling, electrical, inlet/exhaust, installation, and oil specs for MINI-33 to MINI-55.
Table of torque values for critical nuts and screws on MINI-17/MINI-29 engines.
Index page for electrical wiring diagrams.
Index page for engine overall dimension drawings.
Detailed dimensions and technical data for various engine models.
Information on replacing engines and disposing of parts according to law.
Fields for installer, marina, and owner details.
Fields for engine, gearbox, fuel, cooling, and exhaust line information.
Checklists for pre-start up and no-load engine operations.
Checks for engine operation with propeller load and owner information delivery.
Index page for the Declaration of Conformity document.
Manufacturer's declaration of compliance with EU directives for engine types.
Engine model identification and conformity certificate numbers.
Table for specifying compliance with harmonized standards and directives.
Manufacturer's declaration for MINI-55 engine compliance with EU directives.
Table for specifying compliance with harmonized standards and directives.
Blank log for recording engine maintenance dates, hours, and service.
General| Engine Type | Diesel |
|---|---|
| Cylinders | 3 |
| Max RPM | 3600 rpm |
| Cooling System | Freshwater cooled |
| Starting System | Electric |
