Sony CDX-G1200U - Warning; Regulatory Compliance

CDX-G1200U/G1201U/G1202U/G1280UM
2
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be dam-
aged by heat.
FLEXIBLE CIRCUIT BOARD REPAIRING
• Keep the temperature of soldering iron around 270 °C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specifi ed herein may result in hazardous radia-
tion exposure.
1. SERVICING NOTES ............................................. 3
2. GENERAL .................................................................. 7
3. DISASSEMBLY
3-1. Disassembly Flow ........................................................... 13
3-2. Mini Fuse (Blade Type) (FU1), Cover ............................ 13
3-3. Sub Panel Assy ................................................................ 14
3-4. CD Mechanism Deck (MG-101CF-188) ........................ 14
3-5. MAIN Board ................................................................... 15
3-6. Service Position .............................................................. 15
4. DIAGRAMS
4-1. Block Diagram - MAIN Section - ................................... 16
4-2. Block Diagram
- PANEL/POWER SUPPLY Section - ............................ 17
4-3. Printed Wiring Boards - MAIN Section (1/2) - .............. 18
4-4. Printed Wiring Boards - MAIN Section (2/2) - .............. 19
4-5. Schematic Diagram - MAIN Section (1/4) - ................... 20
4-6. Schematic Diagram - MAIN Section (2/4) - ................... 21
4-7. Schematic Diagram - MAIN Section (3/4) - ................... 22
4-8. Schematic Diagram - MAIN Section (4/4) - ................... 23
5. EXPLODED VIEWS
5-1. Sub Panel Section ........................................................... 31
5-2. Chassis Section ............................................................... 32
6. ELECTRICAL PARTS LIST .............................. 33
Accessories are given in the last of the electrical parts list.
TABLE OF CONTENTS
–Neither the name of the Xiph.org
Foundation nor the names of its
contributors may be used to endorse or
promote products derived from this
software without specic prior written
permission.
THIS SOFTWARE IS PROVIDED BY THE
COPYRIGHT HOLDERS AND CONTRIBUTORS
“AS IS” AND ANY EXPRESS OR IMPLIED
WARRANTIES, INCLUDING, BUT NOT LIMITED
TO, THE IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE ARE DISCLAIMED. IN
NO EVENT SHALL THE FOUNDATION OR
CONTRIBUTORS BE LIABLE FOR ANY DIRECT,
INDIRECT, INCIDENTAL, SPECIAL,
EXEMPLARY, OR CONSEQUENTIAL DAMAGES
(INCLUDING, BUT NOT LIMITED TO,
PROCUREMENT OF SUBSTITUTE GOODS OR
SERVICES; LOSS OF USE, DATA, OR PROFITS;
OR BUSINESS INTERRUPTION) HOWEVER
CAUSED AND ON ANY THEORY OF LIABILITY,
WHETHER IN CONTRACT, STRICT LIABILITY,
OR TORT (INCLUDING NEGLIGENCE OR
OTHERWISE) ARISING IN ANY WAY OUT OF
THE USE OF THIS SOFTWARE, EVEN IF
ADVISED OF THE POSSIBILITY OF SUCH
DAMAGE.
CAUTION
The use of optical instruments with this
product will increase eye hazard.
SAFETY-RELATED COMPONENT WARNING!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONC-
TIONNEMENT. NE REMPLACER CES COMPOSANTS QUE
PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DON-
NÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
Windows Media is either a registered
trademark or trademark of Microsoft
Corporation in the United States and/or
other countries.
T
his product is protected by certain
intellectual property rights of Microsoft
Corporation. Use or distribution of such
technology outside of this product is
prohibited without a license from Microsoft
or an authorized Microsoft subsidiary.
MPEG Layer-3 audio coding technology and
patents licensed from Fraunhofer IIS and
T
homson.
Android is a trademark of Google Inc.
libFLAC
Copyright (C) 2000-2009 Josh Coalson
Copyright (C) 2011-2013 Xiph.Org Foundation
Redistribution and use in source and binary
forms, with or without modication, are
permitted provided that the following
conditions are met:
– Redistributions of source code must retain
the above copyright notice, this list of
conditions and the following disclaimer.
– Redistributions in binary form must
reproduce the above copyright notice, this
list of conditions and the following
disclaimer in the documentation and/or
other materials provided with the
distribution.
Copyrights
• US and CND models:
• EA model:
T
his product is classied as a Class 1 Laser
product under IEC 60825-1:2007.
T
his label is located on bottom surface of
the product.