Sony HCD-FX200 User Manual

SERVICE MANUAL
Sony Corporation
Audio&Video Business Group
Published by Sony Techno Create Corporation
HCD-FX200/FX205
SPECIFICATIONS
COMPACT DISC RECEIVER
9-889-800-02
2010D05-1
©
2010.04
AEP Model
HCD-FX200/FX205
E Model
Australian Model
HCD-FX200
Ver. 1.1 2010.04
• HCD-FX200 is the amplifi er, CD player, tuner
and USB section in CMT-FX200.
• HCD-FX205 is the amplifi er, CD player, tuner
and USB section in CMT-FX205. Photo: HCD-FX200
Model Name Using Similar Mechanism
NEW
Base Unit Name
BU-D1BD73U
Optical Pick-up Block Name
DA11MMVGP
 MPEG Layer-3 audio coding technology and patents
licensed from Fraunhofer IIS and omson.
 All other trademarks and registered trademarks are of
their respective holders. In this manual,
TM
and
®
marks
are not specied.
Amplier section
European and Russian models:
DIN power output (rated): 4 watts + 4 watts (4 ohms at 1 kHz, DIN)
Continuous RMS power output (reference): 5 watts + 5 watts (4 ohms at
1 kHz, 10% THD)
Music power output (reference): 9 watts + 9 watts
Other models:
DIN power output (rated): 4 watts + 4 watts (4 ohms at 1 kHz, DIN)
Continuous RMS power output (reference): 5 watts + 5 watts (4 ohms at
1 kHz, 10% THD)
Input
AUDIO IN (stereo mini jack): Sensitivity 550 mV, impedance 50 kilohms
Outputs
PHONES (stereo mini jack): Accepts headphones with an impedance of
8 ohms or more
SPEAKERS: Accepts impedance of 4 ohms
CD player section
System: Compact disc and digital audio system
Laser Diode Properties
Emission Duration: Continuous
Laser Output*: Less than 44.6μW
* is output is the value measurement at a distance of 200mm from the
objective lens surface on the Optical Pick-up Block with 7mm aperture.
Frequency response: 20 Hz – 20 kHz
Signal-to-noise ratio: More than 90 dB
Dynamic range: More than 90 dB
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section:
Tuning range
87.5 MHz – 108.0 MHz (50 kHz step)
Antenna: FM lead antenna
Intermediate frequency: 225 kHz
AM tuner section:
Tuning range
Models for Europe, Russia, Saudi Arabia:
531 kHz – 1,602 kHz (9 kHz step)
Australian model:
531 kHz – 1,710 kHz (9 kHz step)
530 kHz – 1,710 kHz (10 kHz step)
Latin American models:
530 kHz – 1,710 kHz (10 kHz step)
531 kHz – 1,710 kHz (9 kHz step)
Other models:
531 kHz – 1,602 kHz (9 kHz step)
530 kHz – 1,610 kHz (10 kHz step)
Antenna: AM loop antenna
Intermediate frequency: 53 kHz
USB section
Supported bit rate:
MP3 (MPEG 1 Audio Layer-3): 32 kbps – 320 kbps, VBR
Sampling frequencies:
MP3 (MPEG 1 Audio Layer-3): 32/44.1/48 kHz
(USB) port: Type A, maximum current 500 mA
General
Power requirements:
European and Russian models: AC 230 V, 50/60 Hz
Australian model: AC 230 V – 240 V, 50/60 Hz
Latin American models (except for Brazilian, Mexican and Argentine
models): AC 110 V – 120 V or 220 V – 240 V, 50/60 Hz, adjustable with
voltage selector
Argentine model: AC 220 V, 50/60 Hz
Models for Middle and Near East: AC 110 V – 120 V or 220 V – 240V,
50/60 Hz, adjustable with voltage selector
Korean model: AC 220 V, 60 Hz
Taiwan model: AC 120 V, 50/60 Hz
Other models: AC 220 V – 240 V, 50/60 Hz
Power consumption:
European and Russian models: 28 watts
Latin American models (except for Mexican and Argentine models):
28 watts
Models for Middle and Near East: 28 watts
Other models: 25 watts
Dimensions (W/H/D) (excl. speakers):
Approx. 158 mm × 240 mm × 225.5 mm
Mass (excl. speakers): Approx. 2.1 kg
Design and specications are subject to change without notice.
ai model: AC 220 V, 60 Hz
sStandby power consumption: 0.5 W
wiring boards.
sHalogenated ame retardants are not used in the certain printed

Sony HCD-FX200 Specifications

General

CD Player	Yes
Tape Deck	Yes
Radio Tuner	Yes
USB Port	No
MP3 Playback	Yes
WMA Playback	Yes
Remote Control	Yes
Type	Mini HiFi System
Tuner Bands	AM, FM
Speaker Output	2 speakers

Summary

SPECIFICATIONS

Amplifier Section

Details on power output, impedance, and sensitivity for amplifier.

CD Player Section

Technical specifications for the CD player system, including laser properties.

Tuner Section

Specifications for FM stereo and AM superheterodyne tuner sections.

USB Section

Details on supported bit rates and sampling frequencies for USB audio.

General Specifications

Power requirements, consumption, dimensions, and mass of the unit.

SECTION 1 SERVICING NOTES

Handling Optical Pick-up Block and Base Unit

Precautions for handling the optical pick-up block and base unit to prevent electrostatic breakdown.

Laser Diode Emission Check

Guidelines for checking laser diode emission safely from a distance.

Unleaded Solder Handling

Information and precautions regarding the use and characteristics of unleaded solder.

Laser Diode and Focus Search Operation Check

Procedure for visually checking laser diode emission and focus search operation.

SECTION 2 DISASSEMBLY

Disassembly Flow

Overview of the set's disassembly sequence.

Panel (Rear) Block Disassembly

Step-by-step instructions for disassembling the rear panel.

Top Panel Block Disassembly

Procedure for removing the top panel assembly.

Front Panel Block Disassembly

Instructions for disassembling the front panel assembly.

Knob (VOL) Removal

Method for removing the volume knob.

Main Board Access

Steps to access and remove the main board.

Base Unit (BU-D1BD73U) Removal

Procedure for removing the base unit.

Optical Pick-up Block (DA11MMVGP) Removal

Instructions for removing the optical pick-up block.

SECTION 3 TEST MODE

Cold Reset Procedure

How to perform a cold reset to clear memory to initial conditions.

Panel Test Mode Entry

Steps to enter the panel test mode for display segment check.

Version Check Procedure

How to check the displayed version and micom version.

Tuner Step Change

Procedure to change the AM tuning interval (9 kHz/10 kHz).

CD/USB Power Manage Mode

How to switch CD/USB power supply on/off.

CD Service Mode

Procedure to enter CD service mode for SLED and laser power control.

SECTION 4 ELECTRICAL CHECK

CD Section Electrical Checks

Notes on CD block operation and checks without adjustment.

Focus Bias Check

Procedure for checking focus bias using an oscilloscope.

SECTION 5 DIAGRAMS

Block Diagram - CD, Tuner, USB Section

Block diagram illustrating the signal path for CD, Tuner, and USB.

Block Diagram - Output, Panel, Power Supply Section

Block diagram for output, panel, and power supply sections.

Printed Wiring Board - BD73U Board

Component layout for the BD73U board.

Schematic Diagram - BD73U Board

Circuit diagram for the BD73U board.

Printed Wiring Board - USB Board

Component layout for the USB board.

Schematic Diagram - USB Board

Circuit diagram for the USB board.

Schematic Diagram - MAIN Section (1/2)

Circuit diagram for the main board (part 1).

Schematic Diagram - MAIN Section (2/2)

Circuit diagram for the main board (part 2).

Printed Wiring Boards - MAIN Section

Component layout for the main board.

Printed Wiring Board - PANEL Board

Component layout for the panel board.

Schematic Diagram - PANEL Board (1/2)

Circuit diagram for the panel board (part 1).

Schematic Diagram - PANEL Board (2/2)

Circuit diagram for the panel board (part 2).

Printed Wiring Board - PT Board

Component layout for the PT board (except specific models).

Schematic Diagram - PT Board

Circuit diagram for the PT board (except specific models).

Printed Wiring Board - PT-SW Board

Component layout for the PT-SW board (specific models).

Schematic Diagram - PT-SW Board

Circuit diagram for the PT-SW board (specific models).

IC Block Diagrams

BD73U Board IC Block Diagrams

Internal block diagrams for ICs on the BD73U board.

MAIN Board IC Block Diagrams

Internal block diagrams for ICs on the main board.

PANEL Board IC Block Diagrams

Internal block diagrams for ICs on the panel board.

IC Pin Function Description

USB Board IC101 Pin Functions

Detailed pin function description for the USB controller IC101.

Panel Board IC801 Pin Functions

Detailed pin function description for the system controller IC801.

SECTION 6 EXPLODED VIEWS

Overall Section Exploded View

Exploded view of the entire unit with parts identification.

Top Panel Section Exploded View

Exploded view of the top panel assembly and its components.

Front Panel Section Exploded View

Exploded view of the front panel assembly and its parts.

Chassis Section Exploded View

Exploded view of the chassis and related components.

SECTION 7 ELECTRICAL PARTS LIST

BD73U Board Parts

List of electrical components for the BD73U board.

Capacitor Parts List

List of capacitors with part numbers, descriptions, and values.

Connector Parts List

List of connectors with part numbers and types.

IC Parts List

List of integrated circuits with part numbers and descriptions.

Transistor Parts List

List of transistors with part numbers and types.

Resistor Parts List

List of resistors with part numbers, values, and tolerances.