Copyright © WESSOL, LLC
16
TORNADO | SMSASM Operation Guide
TROUBLESHOOTING YOUR SPRAYER
To contact Technical Support, message support@wessol.com.
PROBLEM POSSIBLE REASON(S) SOLUTION
Sprayer is not turning on
and there is no sound
coming from the sprayer.
Dead battery
Charge the battery. If the battery will not charge, test the charger or contact Support for a
replacement if under warranty.
Loose/worn connections on power
switch
Remove back plate. Using pliers, move all three wires on the power switch over to the
neighboring side, to the extra set of wire contacts.
Defective micro-switch Purchase replacement part or contact Support for help.
Defective circuit board Purchase replacement part or contact Support for help.
Leaks from gun/nozzle
area.
Loose connection Ensure spray handle is fully tightened onto threaded end of the hose.
Missing or worn gasket Contact Support or go to buyspraymate.com to purchase replacement gaskets.
Clogged pump / hose / gun /
wand / nozzle.
Not rinsing tank / pump / hose /
gun / nozzle(s) with water
after use.
Rinse sprayer throughly with warm, soapy water after each use.
Dead battery
Defective charger
If the LED indicator lights do not turn on or only one red LED is on after being on
charger for over 2 hours, test the charger using a multimeter. Replace if necessary.
Damaged lithium cells If the battery receives no reading from a multimeter, a replacement battery is needed.
Pump makes a sound when
sprayer is on and output is
Clog in lter or nozzle Check lter or nozzles for clog. Using warm water, throughly clean the components.
Clog in pump Open the pump and clean. Contact Support for assistance.
Leak from sprayer tank
Loose hose-pump connection Open back plate and identify the hose clamps. Use a athead screwdriver to tighten.
Damage on pump Replace the pump.
Damage on tank Replace the sprayer tank.
To Next Page
Loading...