Stanley AC6511 - Safety Guidelines; Operational Safety Rules

5
LUBRICATION OF COMPRESSOR
4HISAIRCOMPRESSORIS/),&2%%4HEREFORETHEREIS./OILUSEDFOR
LUBRICATION
ASSEMBLY
4HISCOMPRESSOR-534BEFULLYASSEMBLEDBYYOUPRIORTOUSE&AILURE
TODOSOWILLRESULTINTHEWARRANTYBEING6/)$&AILURETOFULLY
ASSEMBLETHISCOMPRESSORMAYALSORESULTINPERSONALINJURY
SAFETY
"EFOREATTEMPTINGTOOPERATETHISAIRCOMPRESSORTHEFOLLOWINGBASIC
SAFETYPRECAUTIONSSHOULDBETAKENTOREDUCETHERISKOFlREELECTRIC
SHOCKANDPERSONALINJURY)TISIMPORTANTTOREADTHEINSTRUCTION
manual and to understand applications, limitations and potential
HAZARDSASSOCIATEDWITHTHEAIRCOMPRESSOR4HISAIRCOMPRESSORISNOT
INTENDEDFORUSEBYPERSONSINCLUDINGCHILDRENWITHREDUCEDPHYSICAL
SENSORYORMENTALCAPABILITIESORLACKOFEXPERIENCEANDKNOWLEDGE
UNLESSTHEYHAVEBEENGIVENSUPERVISIONORINSTRUCTIONCONCERNINGTHE
USEOFTHEAPPLIANCEBYAPERSONRESPONSIBLEFORTHEIRSAFETY
BEWARE OF CHILDREN AND PETS
#HILDRENANDPETSSHOULDBEKEPTOUTOFTHEWORKAREA#HILDREN
SHOULDNOTBEALLOWEDTOTOUCHOROPERATETHEAIRCOMPRESSOR
TOOLSOREXTENSIONCORDS4HISAIRCOMPRESSORISNOTDESIGNEDFOR
USEBYYOUNGCHILDRENORINFIRMPERSONSWITHOUTSUPERVISION4HE
AIRCOMPRESSORANDTOOLSSHOULDBEKEPTOUTOFREACHOFCHILDREN
PREFERABLYSTOREDORLOCKEDINASECURECABINETORROOMWHENNOT
in use.
WORK AREA
7ORKAREASANDBENCHESSHOULDBEKEPTTIDY#LUTTEREDBENCHESAND
WORKAREASCANCAUSEACCIDENTS&LOORSSHOULDBEKEPTCLEANANDFREE
FROMRUBBISH3PECIALCARESHOULDBETAKENWHENTHEmOORISSLIPPERY
DUETOSAWDUSTORWAX!LWAYSLEAVESUFlCIENTDISTANCEATLEAST
METRESBETWEENTHEAIRCOMPRESSORANDTHEWORKAREAESPECIALLY
when using tools designed for sanding or spraying liquids.
WORK ENVIRONMENT
Do not expose your air compressor to rain or use in damp or wet
conditions. Keep the work area well lit.
GUARD AGAINST ELECTRIC SHOCK
!VOIDBODYCONTACTWITHEARTHEDORGROUNDEDSURFACESEGPIPESAND
REFRIGERATORS
DO NOT FORCE AIR COMPRESSORS
4HEAIRCOMPRESSORWILLDOABETTERSAFERJOBANDGIVEYOUMUCHBETTER
SERVICEIFITSUSEDATTHEDUTYCYCLEFORWHICHITWASDESIGNED4HE
DUTYCYCLEWILLONLYTAKEEFFECTAFTERTHEINITIALSTTANKlLLFORTHEDAY
4HISAIRCOMPRESSORSDUTYCYCLEIS$UTYCYCLEISTHEPROPORTIONOF
time during which the air compressor is operating compared with not
OPERATING&OREXAMPLEADUTYCYCLECOULDMEANAFTERSECONDS
OFOPERATIONMOTORPUMPINGTHEAIRCOMPRESSORMUSTBELEFTFOR
SECONDSRESTINGMOTORNOTPUMPING7HENTHEMOTORISPUMPINGTHE
ATTACHEDAIRTOOLCANNOTBEUSED/NLYUSETHEATTACHEDAIRTOOLWHILE
the compressor is not pumping. Stop using the attached tool as soon
as the air compressor starts pumping.
USE THE RIGHT TOOL
3ELECTTHERIGHTTOOLFORTHEJOB$ONOTUSEATOOLFORAJOBFORWHICH
it was not designed. Do not force a small air compressor to do the
JOBOFAHEAVYnDUTYAIRCOMPRESSOR$ONOTUSETHEAIRCOMPRESSORFOR
purposes not intended.