Suburban SW6PR User Manual

INSTALLATION AND OPERATION MANUAL
DIRECT VENT
GAS WATER HEATER
LISTED
MODELS
SW6P • SW6PE • SW6D • SW6DM
SW6PR • SW6PER • SW6DE
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
1. DO NOT TRY TO LIGHT ANY APPLIANCE.
2. DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
BUILDING.
3. IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE.
FOLLOW THE GAS SUPPLIER'S INSTRUCTIONS.
4. IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE
DEPARTMENT.
FREEZE WARNING
_ DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES. _
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE
OR MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO
THIS MANUAL. FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT
A QUALIFIED INSTALLER, SERVICE AGENCY OR THE GAS SUPPLIER. _
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR
LIQUIDS NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE.
THIS APPLIANCE SHALL NOT BE INSTALLED IN ANY LOCATION WHERE
FLAMMABLE LIQUIDS OR VAPORS ARE LIKELY TO BE PRESENT.
AN ODORANT IS ADDED TO THE GAS USED BY THIS WATER HEATER.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO WATER HEATER.
OWNER: RETAIN THESE INSTRUCTIONS AND WARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULD BE DIRECTED TO THE COMPANY
LISTED ON THE WARRANTY, OR RATING PLATE WHICH CAME WITH YOUR WATER HEATER.
SUBURBAN MANUFACTURING COMPANY
Post Office Box 399
Dayton, Tennessee 37321
(615) 775-2131
Fax: (615) 775-7015
Form No. 2119-C
4-93

Suburban SW6PR Specifications

General

Capacity	6 Gallons
Recovery Rate	40 gallons per hour
Weight	32 lbs
Input BTU	12, 000 BTU
Ignition Type	Direct Spark
BTU/h Input	12, 000 BTU
Dimensions (Height x Diameter in Inches)	12-1/2 x 12-1/2
Weight (lbs)	32

Summary

Installation Requirements and Instructions

Installation Instructions

Details on clearances, openings, and framing for installation.

Flush Mount and Hinged Door Installation

Step-by-step guides for installing with flush mount or hinged doors.

Making Water, Gas, and Electrical Connections

Procedures for connecting water, gas, and electrical lines to the heater.

Re-Ignitor and Motor Aid Connections

Specifics for re-ignitor electrical connections and motor aid installation.

Maintenance, Safety, and Service

Safety Warnings

Crucial safety precautions and warnings for operation and installation.

Anode Protection and Pressure Relief Valve

Information on the anode rod, relief valve function, and maintenance.

Thermostat, Draining, and Odor Issues

Details on thermostat operation, draining, storage, and odor troubleshooting.

Removing the Water Heater

Steps for safely removing the water heater from its installation.

Operating and Lighting Procedures

Operating and Lighting Instructions (Pilot Models)

How to safely operate and light the water heater with a pilot system.

Operating Instructions (Automatic Ignition)

Instructions for operating models with automatic ignition systems.

Lighting Instructions for Re-Ignitor Control

Specific steps for lighting models equipped with a re-ignitor.

Limited Warranty Information

One Year Limited Warranty

Details on the one-year warranty for parts and workmanship.

Three Year Limited Warranty on Tank

Information on the extended three-year warranty for the inner tank.

Warranty Limitations and Exclusions

Conditions and exclusions that may affect warranty coverage.