Superior BBV-36RMP - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
INSTALLATION
INSTRUCTIONS
STANDARD SERIES
36" B-VENTED GAS APPLIANCES
P/N 700,000M REV. H 07/2004
Millivolt Models Electronic Models
BBV-36RMN BBV-36REN
BBV-36RMP BBV-36REP
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
WH Report No. J99025850
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
MODELS
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
This appliance may be installed in an after-
market permanently located, manufactured
home (USA only) or mobile home, where not
prohibited by local codes. This appliance is
only for use with the type of gas indicated on
the rating plate. This appliance is not convert-
ible for use with other gases, unless a certi-
fied kit is used.

Summary

Models

Millivolt Models

Lists the specific millivolt model numbers for the appliance.

Electronic Models

Lists the specific electronic model numbers for the appliance.

Introduction

General Information

Provides general details about the appliance's design and compliance.

Location

Guidance on selecting an appropriate and safe installation location.

Clearances

Specifies minimum clearance requirements to combustible materials.

Appliance Specifications

Details the physical dimensions and specifications of the appliance.

Gas Vent Rule

Rules and guidelines regarding gas vent termination and clearances.

Framing Specifications

Provides dimensions and requirements for framing the appliance enclosure.

Typical Installation Sequence

Outlines the general order of steps for installing the appliance.

Installation

Details the primary steps and considerations for installing the appliance.

Vent System Installation

Instructions for installing the gas vent system and termination.

Field Wiring

Instructions for electrical wiring of millivolt and electronic appliances.

Connecting Gas Line

Procedure for connecting the gas supply line to the appliance.

Outside Air Kit Installation

Guidance on installing the optional outside air kit.

Log and Rockwool Installation

Instructions for placing logs and rockwool inside the firebox.

Appliance Operation

Details on checking the system and operating the appliance.

Manually-Reset Blocked Flue Safety Switch

Information on the safety switch and how to reset it.

Millivolt Appliance Checkout

Procedure for checking the operation of millivolt appliances.

Electronic Appliance Checkout

Procedure for checking the operation of electronic appliances.

Adjustments

Guidance on adjusting flame appearance and soot conditions.

Finishing Requirements

Instructions for completing the interior wall and mantel finishes.

Cold Climate Insulation

Recommendations for insulating the appliance in cold climates.

Installation Accessories

Lists available accessory items for installation.

Gas Conversion Kits

Instructions and kit numbers for converting gas types.

Framing Specifications

Pre-Installation Notes

Important considerations before beginning fireplace installation.

Installing the Fireplace

Step-by-step instructions for physically installing the fireplace unit.

Appliance Specifications

Venting

Information and rules regarding gas vent system installation.

Superior BBV-36RMP Specifications

General

Brand	Superior
Model	BBV-36RMP
Category	Indoor Fireplace
Language	English