Suzuki GP125 - Periodic Maintenance Schedule

2-1
PERIODIC MAINTENANCE SCHEDULE
Vehicles
should
be
inspected
after
а
certain
period
of
running
for
wear
of
parts,
carbon
deposits,
elongated
cables,
etc.
Inspections
should
be
made
periodically
and
defects
should
be
repaired
or
adjusted
beforehand
to
prevent
trouble
and
prolong
the
motorcycle’s
service
life.
Inspect and
adjust
the
vehicle
as
indicated
below.
NOTE
More frequent maintenance may be performed on motorcycles that are used in an extreme service
condition:
PERIODIC MAINTENANCE CHART
Engine
eral | Initio! 1 000 em
= initia 600 miles
Contact breaker Check contest point
prep em
peas pr
mop screw, pilot i
adjust serow and
| Oi pump Check operation, adjust
[revelan
Fuel hose |
Fuel strainer | Clean
Cylinder пев tighten eyinder
and cylinder мет
Смет Глам
==] Change
Battery | Check & service
Chassis
Г Interval | Initial 1 000 km.
tom initial 600 miles
Bolts and nuts
Drive chain.
Front brake (GP125)
Front brake (GP125U)_
Нем brake
Steering stem
Retighten
Adjust
Check fluid level,
Jeakage and pad
Adiust play
Adjust play
Adjust play
Every 3 000 km
Every 2 000 miles
Clean and adjust gap
Wash
Adjust throttle valve
stop screw, pilot
adjust screw and
Check operation,
control lever aligning
зар and ignition timing
| Every 6 000 кт
Every 4 000 miles
Replace
Replace every 2 years.
T Retighten cylinder
head тиз
Adjust
Change
| Check & service.
electrolyte solution
Every 3 000 km
Every 2 000 miles
Adjust
| Check fuid level
leakage and pad
Adjust play
Adjust play
Clean
Remove carbon
T Every 6 000 кт
Every 4 000 miles
Retighten
Wash
Every 12 000 km
Every 8 000 miles
æ (only for
point type) |
Ovérhau! and clean
Every 12 000 km
Every 8 000 miles
дд