Suzuki JB419 - Maintenance and Lubrication; Precautions for Maintenance and Lubrication; Engine Maintenance; Ignition System Maintenance

0B-1 Maintenance and Lubrication:
General Info rmation
Maintenance and Lubrication
Precautions
Precautions for Maintenance and Lubrication
S6JB0A0200001
Air Bag Warning
Refer to “Air Bag Warning in Section 00”.
Scheduled Maintenance
Maintenance Schedule under Normal Driving Conditions (Petrol Engine Model)
S6JB0A0205001
NOTE
• This interval should be judged by odometer reading or months, whichever comes first.
• This table includes service as scheduled up to 90,000 km (54,000 miles) mileage. Beyond 90,000 km
(54,000 miles), carry out the same services at the same intervals respectively.
Interval
Km (x 1,000) 15 30 45 60 75 90
Miles (x 1,000) 9 18 27 36 45 54
Months 12 24 36 48 60 72
Engine
Accessory drive belt (I: ), R: ))——I——R
Valve lash (clearance) (I: ))—I—I—I
Engine oil and oil filter (R: ))RRRRRR
Engine coolant (R: ))——R——R
Exhaust system (I: ))—I—I—I
Ignition system
*Spark plugs (R: ))
When unleaded
fuel is used
Vehicle with A/F
sensor
Nickel Plug — — R — — R
Iridium Plug
(Highly recommended)
Replace every 105,000 km
(63,000 miles) or 84 months
Vehicle without A/
F sensor
Nickel Plug — R — R — R
Iridium Plug — — — R — —
When leaded fuel is used, refer to “Maintenance Recommended under Severe Driving
Conditions (Petrol Engine Model)”.
Fuel system
Air cleaner filter (I: ), R: ))
Paved-road I I R I I R
Dusty conditions
Refer to “Maintenance
Recommended under Severe
Driving Conditions (Petrol Engine
Model)”.
Fuel lines and connections (I: ))—I—I—I
Fuel filter (R: ))
Replace every 105,000 km
(63,000 miles)
Fuel tank (I: ))——I——I
Emission control system
Crankcase ventilation hoses and connections (vehicle without A/F sensor) (I: ))— — I ——I
*PCV valve (I: ))
Vehicle with A/F sensor — — — — — I
Vehicle without A/F sensor — — I — — I
*Fuel evaporative emission control
system (I: ))
Vehicle with A/F sensor — — — — — I
Vehicle without A/F sensor — I — I — I
Brake
Brake discs and pads (thickness, wear, damage) (I: ))IIIIII
Brake drums and shoes (wear, damage) (I: ))—I—I—I
Brake hoses and pipes (leakage, damage, clamp) (I: ))—I—I—I
Brake fluid (R: ))—R—R—R
Brake lever and cable (damage, stroke, operation) (I: ))
Inspect at first 15,000 km (9,000
miles only)