15-515-5TX / TXH / TXB 180S - 400L (Rev. 4/23/07)TX / TXH / TXB 180S - 400L (Rev. 4/23/07)
COUPLINGCOUPLING
NUTNUT
Illustration Illustration 15-6. 15-6. Parking Brake Parking Brake (Plug Removed)(Plug Removed)
7.7. EveEven up thn up the rune runninning cleg clearaarance 0nce 0.01.010 - 0.00 - 0.01515
inch (0.25-0.38 mm) on each side of the discinch (0.25-0.38 mm) on each side of the disc
by adjusting the socket head cap screw (17,by adjusting the socket head cap screw (17,
nated and can cause incorrect operation.nated and can cause incorrect operation.
Damage to components can result.Damage to components can result.
1.1. ParPark the tk the trucruck on a hak on a hard, lrd, leveevel surl surfacface, ape, applyply
parking brake and block the wheels of theparking brake and block the wheels of the
truck in both directions to prevent movement.truck in both directions to prevent movement.
2.2. WitWith the enh the engingine runne runninging, hav, have some someone aeone applpplyy
one of the service brake pedals and hold itone of the service brake pedals and hold it
down.down.
3.3. OpeOpen the bn the bleeleeder vder valvalve aboe about 1/ut 1/2 tur2 turn on thn on thee
left front wheel brake housing, allowing air andleft front wheel brake housing, allowing air and
oil to vent into a suitable container.oil to vent into a suitable container.
MANUALMANUAL
OVERRIDE KNOBOVERRIDE KNOB
Illustration Illustration 15-7. 15-7. Parking Parking Brake Brake SolenoidSolenoid
4.4. CloClose thse the blee bleedeeder valr valve anve and thed then reln releasease thee the
brake pedal.brake pedal.
5.5. RepRepeat peat procroceduedures 2res 2., 3.., 3., and 4, and 4. unt. until ail a
bubble-free flow of fluid is observed while con-bubble-free flow of fluid is observed while con-
tinuing to check the level of fluid in the hydrau-tinuing to check the level of fluid in the hydrau-
lic tank.lic tank.
6.6. RepRepeat peat procroceduedures 2res 2. thr. througough 5. to blh 5. to bleed teed thehe
right service brake.right service brake.
Parking Brake SolenoidParking Brake Solenoid (Illustration 15-7)(Illustration 15-7).. TheThe
parking brake solenoid of the manifold can beparking brake solenoid of the manifold can be
enough pressure is available by the accumulators.enough pressure is available by the accumulators.
To return to normal parking brake operation, fullyTo return to normal parking brake operation, fully
turn the manual override knob out counterclock-turn the manual override knob out counterclock-
wise.wise.
Drive Axle Service Brakes ServicingDrive Axle Service Brakes Servicing
Death, serious injury or pro-Death, serious injury or pro-
perty damage may occur from improperlyperty damage may occur from improperly
i t i ii t i i th ith i b kb k II
https://www.forkliftpdfmanuals.com/
To Next Page
Loading...
