22-1722-17TX / TXH / TXB 180S - 400L (Rev. 4/23/07)TX / TXH / TXB 180S - 400L (Rev. 4/23/07)
y ) py ) p
calibrated.calibrated.
9.9. LoLoosose or be or brorokeken pln plugugs / pis / pins /ns /
wires between the TICS compo-wires between the TICS compo-
nents (i.e. display / modules / joys-nents (i.e. display / modules / joys-
tick / solenoids).tick / solenoids).
9.9. IsIsololatate ae and nd ReRepapairir..
4.4. SlSlow ow or or no no TTililt It Inn
1.1. OpeOperatrator ior is nos not st seateated ied in thn the ope oper-er-
ators seat.ators seat.
2.2. DefDefectective ive floflow cow contrntrol iol in one n one of tof thehe
tilt cylinders.tilt cylinders.
3.3. TTilt vilt valvalve’s e’s maimain spon spool is sol is stuctuck.k.
4.4. CenCentertering ing sprspringing(s) (s) of of the the lifliftt
valve’s main spool is broken.valve’s main spool is broken.
5.5. DefDefectective ive solsolenoenoid oid or car cartrrtridgidge one on
the lift valve.the lift valve.
6.6. TICTICS (TS (Taylaylor Intor Integregrateated Contd Controlrol
System) tilt in operation is mis-cali-System) tilt in operation is mis-cali-
brated.brated.
7.7. LoLoosose or be or brorokeken pln plugugs / pis / pins /ns /
wires between the TICS compo-wires between the TICS compo-
nents (i.e. display / modules / joys-nents (i.e. display / modules / joys-
tick / solenoids).tick / solenoids).
1.1. RetReturn urn to to the the operoperatoators rs seaseat.t.
22.. RReeppllaaccee..
3.3. RemRemove ove maimain sn spoopool, l, cleclean an andand
re-assemble. re-assemble. Inspect Inspect valve valve hous-hous-
ing for debris.ing for debris.
44.. RReeppllaaccee..
5.5. ActActivaivatiotion of n of the the manmanual ual oveoverrirridede
switch will confirm defective sole-switch will confirm defective sole-
noid. Replace.noid. Replace.
66.. CCaalliibbrratatee..
7.7. IsIsololatate e and and reprepaiairr..
55.. NNo o oor r ssllooww
steeringsteering
continuedcontinued
1.1. SteSteer cer cyliylindender pisr piston ton pacpackinking isg is
defective.defective.
2.2. LogLogic Cic Contontrol (rol (LC2LC2) is r) is restestricricted bted byy
debris (stuck closed).debris (stuck closed).
3.3. LogLogic Cic Contontrol rol (LC(LC2) is 2) is defdefectectiveive..
4.4. LogLogic Cic Contontrol (rol (LC3LC3) is r) is restestricricted bted byy
debris (stuck open).debris (stuck open).
5.5. LogLogic Cic Contontrol rol (LC(LC3) is 3) is defdefectectiveive..
1.1. ReRe-p-pacack stek steer cyer cylilindnderer..
2.2. RemRemove ove and and cleclean an LC2LC2. . InsInspecpectt
LC2’s port for debris.LC2’s port for debris.
33.. RReeppllaaccee..
4.4. RemRemove ove and and cleclean an LC3LC3. . InsInspecpectt
LC3’s port for debris.LC3’s port for debris.
55.. RReeppllaaccee..
PPrroobblleemm CCaauussee CCoorrrreeccttiioonn
55.. NNo o oor r ssllooww
steeringsteering
(Continued)(Continued)
6.6. SteSteer Rer Relieelief (Rf (RV2) V2) is ris restestricricted ted byby
debris (stuck open).debris (stuck open).
7.7. SteSteer Rer Relielief (ef (RVRV2) is 2) is defdefectectiveive..
8.8. MaiMain reln relief (ief (RVRV1) is 1) is resrestritrictected byd by
debris (stuck open)debris (stuck open)
99 MaiMain ren relielief (Rf (RV1) iV1) is des defecfectivtivee
6.6. RemRemove ove and and cleclean an RVRV2. 2. InsInspecpectt
RV2’s port for debris.RV2’s port for debris.
77.. RReeppllaaccee..
8.8. RemRemove ove and and cleclean an RVRV1. 1. InsInspecpectt
RV1’s port for debris.RV1’s port for debris.
99 RReeppllaaccee
To Next Page
Loading...
