Terex T25I and T45I Super Quiet Generator 9
Operating Instructions and Parts Manual
June 2006
REV A
ELECTRICAL SAFETY
THIS EQUIPMENT USES HIGH VOLTAGE CIR-
CUITS CAPABLE OF CAUSING SERIOUS IN-
JURY OR DEATH. EXERCISE EXTREME CAU-
TION AROUND ANY ELECTRICAL COMPO-
NENT WHILE OPERATING THIS UNIT.
Always ground the unit according to local
codes. A grounding lug has been added to the
base frame for your convenience.
Beware of cut or damaged power cords. Have a
qualified electrician replace any damaged cords
immediately.
DO NOT TOUCH HOT PARTS.
The exhaust manifold and tail pipe are very hot.
Parts of the engine are also hot. Use protective
gloves when handling hot parts.
BATTERY HAZARDS
LEAD ACID BATTERIES CAN BE DANGER-
OUS. THE SULFURIC ACID IN THE BATTERY
CAN CAUSE SEVERE SKIN AND EYE BURNS.
THE HYDROGEN GAS EMITTED DURING
CHARGING CAN EXPLODE IF AN ARC OR
FLAME IS PRESENT.
DO NOT smoke while servicing the battery.
DO NOT allow tools to touch battery terminals and
create an arc.
Disconnect the negative terminal of the battery
when working on the engine or other parts to
prevent accidental arcing. Disconnect the negative
cable at the end away from the battery.
DO NOT remove the vent caps when charging the
battery.
Always wear eye protection when servicing the
battery.
If acid gets on skin or eyes, immediately flush
under running water and obtain medical
attention.
KEEP ALL BODY PARTS AND CLOTHING
AWAY FROM MOVING PARTS.
Loose jackets, shirts, sleeves, jewely and espe-
cially neckties should not be worn while working
on or running the unit.
Only remove guards or protective devices from
unit temporarily to gain access for maintenance.
Always replace guards immediately after servic-
ing. Never remove guards while unit is operating.
Keep your hands away from moving parts, particu-
larly clear of the radiator fan and alternator belts
when the engine is running.
BEWARE OF TRAFFIC HAZARDS
Stand clear of traffic when starting or checking the
unit along the road.
Check the fuel tank, oil pan, and fuel and oil lines
for leaks that would spill fuel or oil on the road.
Check fasteners and mounting brackets periodi-
cally to insure all are tight and nothing is in danger
of falling off during transit.
GENERAL SAFETY (Cont.)
To Next Page
Loading...
