Terex T25I and T45I Super Quiet Generator 11
Operating Instructions and Parts Manual
June 2006
REV A
TRANSPORT & TOWING
All trailer-mounted Terex Super Quiet Pac genera-
tors are designed for highway and off road
towing capability. Please consult state and local
transportation codes before transporting the
generator set. Additionally, all state and local
traffic laws take precedence over the following
instructions whenever differences arise between
them.
• Make sure the towing vehicle is of adequate
size to both tow and stop the unit.
• Disconnect all wiring and cabling (including the
ground wire) from the generator set.
• Close and latch or lock all access doors.
• Using the front leveling jack, raise the trailer
hitch to an adequate height so that the
generator can be securely attached to the
transporting vehicle.
• Ensure that the coupler is properly secured to
the towing vehicle and attach the safety chains.
Attach the “breakaway” chain on the surge
brake and the electrical coupler if these options
are included on the unit.
ALWAYS USE THE PROPER TRAILER HITCH
AND SAFETY CHAINS. OBEY ALL
LOCAL OR STATE D.O.T. LAWS WHEN TOW-
ING A GENERATOR.
FAILURE TO PROPERLY SECURE THE
TRAILER TO THE TOWING VEHICLE MAY
RESULT IN SERIOUS INJURY OR DEATH.
• Retract and rotate the front leveling jack into its
stowed position.
EXCEEDING THESE RECOMMENDED SPEEDS
CAN CAUSE SEVERE DAMAGE TO THE UNIT.
DAMAGE CAUSED BY THESE
UNSAFE PRACTICES WILL VOID THE
MANUFACTURER’S WARRANTY.
SETUP
Move the generator set to the desired location
keeping the following in mind:
• The spot where the generator set is positioned
should be relatively level.
• The location selected should be centrally
located to equipment requiring the loads to
minimize voltage drop in the power cord.
• Locate so power cords can be routed without
crossing roads and access routes.
• Locate where the engine will get good
ventilation. Do not locate where fumes will enter
a building.
• Do not place beside a building wall that would
reflect and intensify noise.
Unhitch from the towing vehicle as follows:
• Locate the generator set in the desired location.
• Check the tires for proper inflation and verify
that the lug nuts are tight.
• If equiped with towing lights, connect the
electrical coupler to the towing vehicle.
• Observe posted speed limits for trailers.
Generally, do not exceed 45 mph on paved
roads and 10 mph on unpaved roads.
GENERAL SAFETY (Cont.)
To Next Page
Loading...
