Greenlee Textron / Subsidiary of Textron Inc.
4
4455 Boeing Dr., Rockford, IL 61109-2988 815/397-7070
Hydraulic Punch Driver
IMPORTANT SAFETY INSTRUCTIONS
A component failure could throw
broken parts.
• Do not allow anyone to stand in
front of the punch or behind the
hydraulic ram.
• Close access doors or covers on
any equipment that is in line with
the punch or ram.
Failure to observe this warning can
result in severe injury or death.
Do not attempt to punch a hole
through two or more layers of
material. This will bend or break the
draw stud, and could throw parts
with great force.
Failure to observe this warning can
result in severe injury or death.
Set up the tool properly. An improper setup could
cause a component to fail and strike nearby
personnel with great force.
• Thread the punch completely onto the draw stud.
All of the punch threads must be engaged by the
draw stud threads. Incomplete assembly could
cause a component failure.
• Use only Greenlee punches, dies and draw
studs. Other manufacturers’ components might
not withstand the forces generated by this punch
driver.
Failure to observe these warnings can result in
severe injury or death.
This punch system was designed for a maximum
operating pressure of 450 Bar (6500 psi).
• Use this punch system with the Greenlee 767
Hand Pump or 1725 Foot Pump only.
• Connect the pump to the ram with Greenlee
hoses and couplers only.
Use of any other hoses or couplers could result in
injury from a component failure.
Replace worn, damaged or missing components
with Greenlee replacement parts. Worn or damaged
components can fail, resulting in injury or property
damage.
• Inspect the pump, hoses, couplers, and fittings for
wear or damage.
• Inspect all punch components (punch, die, draw
stud, etc.) for wear or damage.
Failure to observe these warnings can result in
severe injury or death.
Do not exceed the rated capacity of this tool.
Exceeding the rated capacity could cause a
component failure, which could throw broken parts
with great force.
Failure to observe this warning can result in
severe injury or death.
Use this tool for the manufacturer’s intended
purpose only. Any other use can result in injury or
property damage.
The punch driver will fall free when the punch is
complete.
• Support the weight of the tool when punching.
• Do not allow anyone to stand beneath an
overhead punch.
Failure to observe this warning can result in injury
or property damage.
To Next Page
Loading...
