Top Flite Gold Edition Giant F4U Corsair User Manual

WARRANTY.....Top Flite Models guarantees this kit to be free of defects in both material and workmanship at the date of purchase. This warranty does
not cover any component parts damaged by use or modification. In no case shall Top Flite‘s liability exceed the original cost of the purchased kit. Further, Top Flite reserves
the right to change or modify this warranty without notice. In that Top Flite has no control over the final assembly or material used for final assembly, no liability shall be
assumed nor accepted for any damage resulting from the use by the user of the final user-assembled product. By the act of using the user-assembled product the user
accepts all resulting liability. If the buyer is not prepared to accept the liability associated with the use of this product, the buyer is advised to immediately return this kit in
new and unused condition to the place of purchase.
Top Flite Models, Champaign, Il
Phone: (217)398-8970, Ext. 5 airsupport@top-flite.com
CRSGP05 V1.1
READ THROUGH THIS INSTRUCTION BOOK FIRST. IT CONTAINS IMPORTANT INSTRUCTIONS AND WARNINGS CONCERNING THE ASSEMBLY AND USE OF THIS MODEL.
© 2010 Hobbico
®
, Inc.
USA
MADE IN
™

Top Flite Gold Edition Giant F4U Corsair Specifications

General

Brand	Top Flite
Model	Gold Edition Giant F4U Corsair
Category	Toy
Material	Balsa and Plywood
Construction	ARF (Almost Ready to Fly)
Power Source	Gas
Skill Level	Advanced

Summary

Model Introduction and Precautions

Safety Precautions

Crucial safety warning about the model's realistic performance and potential risks.

Tail Surface Construction

Building the Tail Surfaces

Detailed steps for constructing the tail surfaces of the model.

Building the Stabilizer

Instructions for building the stabilizer, including making skins and assembling components.

Fin, Elevator, and Rudder Construction

Building the Fin

Instructions for building the fin, including skinning, ribs, and hinge blocks.

Building the Elevators

Detailed instructions for constructing the model's elevators.

Building the Rudder

Step-by-step guide for building the rudder, including ribs and torque rod installation.

Wing Construction

Building the Wing Center Section

Detailed steps for constructing the central section of the wing.

Building the Wing Tip Panels

Instructions for constructing the wing tip panels.

Joining the Wing Panels

Steps for joining the wing center section and wing tip panels.

Sheeting the Wing Panels

Instructions for sheeting the wing panels with balsa.

Sheeting the Bottom Center Section

Instructions for sheeting the bottom section of the wing center.

Fuselage Construction

Building the Upper Fuse Sides

Steps for building the upper sides of the model's fuselage.

Sheet the Fuse Top

Instructions for sheeting the top section of the fuselage.

Build the Fuse Bottom

Instructions for constructing the bottom section of the fuselage.

Firewall and Wing Mounting

Install the Firewall

Procedure for installing the firewall and engine mount.

Sheet the Bottom of the Fuse

Instructions for sheeting the bottom of the fuselage.

Mount the Wing on the Fuse

Steps for mounting the assembled wing onto the fuselage.

Flap Construction and Controls

Build the Outboard Flaps

Build the Inboard Flaps

Build the Middle Flaps

Install the Flap Controls

Fuselage Finishing and Component Mounting

Finish the Fuselage

Mount the Stabilizer

Finish the Fuse Aft End

Tailgear, Engine, and Cowl Installation

Fit the Retractable Tailgear

Install the Engine

Instructions for mounting the engine and associated components.

Assemble the Cowl

Final Assembly and Checks

Install Hardware

Final Hookups and Checks

Install Hinges

Control Throws and Model Balancing

Set Control Throws

Balance Your Model (CG)

Crucial steps for achieving the correct center of gravity (CG) for stable flight.

Pre-Flight Procedures

Pre-Flight Checks

Pre-flight checks and procedures before the first flight.

Ground and Radio Checks

Safety Codes and Operational Guidance

Engine Safety Precautions

Essential safety precautions for operating model aircraft engines.

AMA Safety Code Excerpts

IMAA Safety Code Excerpts

Operational Guidelines

Flying the Giant Corsair

Guidance and tips for flying the Giant F4U Corsair model.

Flight and Landing Advice

Flight Characteristics

Landing Procedure