Toro 72105 Wheel Horse 268HE User Manual

44 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

Operator’s Manual

IMPORTANT: Read this manual carefully. It contains information about your

safety and the safety of others. Also become familiar with the controls and

their proper use before you operate the product.

International English (GB)

FORM NO. 3321–854

Wheel

Horse



268HE

Lawn & Garden

Tractor

Model No. 72105 – 9900001 & Up

Table of Contents

Questions and Answers:

P
pdavenportAug 1, 2025
What to do if my Toro Lawn Mower engine will not start?
- S
  Stefanie NavarroAug 1, 2025
  If your Toro Lawn Mower engine won't start, starts with difficulty, or fails to keep running, consider the following: 1. Ensure the fuel tank is filled with gasoline. 2. Verify the choke is in the ON position. 3. Check the air cleaner and clean or replace the element if it's dirty. 4. Make sure the spark plug wire is securely connected. 5. Inspect the spark plug; replace it if pitted, fouled, or incorrectly gapped with a new, correctly gapped spark plug. 6. Replace the fuel filter if it's clogged with dirt. 7. If the issue continues, there might be dirt, water, or stale fuel in the fuel system, so contact an Authorized Service Dealer.
M
Mr. Patrick GibsonAug 6, 2025
Why Toro 72105 Wheel Horse 268HE starter does not crank?
- T
  tgordonAug 6, 2025
  If the starter on your Toro Lawn Mower isn't cranking, here are a few things to check: * Ensure the blade control (PTO) is disengaged. * Make sure the parking brake is set. * Confirm that someone is seated on the seat. * Check if the battery is dead and needs charging. * Inspect electrical connections for corrosion or looseness, ensuring good contact. * See if a fuse has blown and needs replacement. * If the issue persists, it could be a defective relay or switch, in which case you should contact an Authorized Service Dealer.
C
Carolyn BellAug 11, 2025
Why is my Toro Lawn Mower engine losing power?
- D
  Debra WhiteAug 11, 2025
  If your Toro Lawn Mower engine is losing power, consider these potential causes: * Reduce ground speed if the engine load is excessive. * Clean a dirty air cleaner element. * Add oil to the crankcase if the oil level is low. * Remove any obstructions from the cooling fins and air passages under the engine blower housing. * Replace the spark plug if it's pitted, fouled, or incorrectly gapped with a new, correctly gapped spark plug. * Clean or replace the fuel cap if the vent hole is plugged. * Replace the fuel filter if it's dirty. * If problems continue, contact an Authorized Service Dealer because there might be dirt, water, or stale fuel in the fuel system.
B
bpetersAug 16, 2025
What to do if my Toro 72105 Wheel Horse 268HE Lawn Mower engine overheats?
- D
  dpittmanAug 16, 2025
  If your Toro Lawn Mower engine is overheating, here are a few possible reasons: * The engine load might be excessive, so try reducing the ground speed. * The oil level in the crankcase might be low, so add oil. * The cooling fins and air passages under the engine blower housing might be plugged, so remove any obstructions.
S
Sally ShermanAug 21, 2025
How to fix abnormal vibration in my Toro 72105 Wheel Horse 268HE?
- J
  Jessica FergusonAug 21, 2025
  If your Toro Lawn Mower is experiencing abnormal vibration, check these: 1. Tighten any loose engine mounting bolts. 2. Tighten any loose engine pulley, idler pulley, or blade pulley. 3. If the engine pulley is damaged, contact an Authorized Service Dealer.
R
Randy ZimmermanAug 27, 2025
What to do if my Toro 72105 Wheel Horse 268HE does not drive?
- P
  Pamela RoblesAug 27, 2025
  If your Toro Lawn Mower doesn't drive, check the following: * Ensure the drive control is in the “OPERATE” position and not in the “PUSH” position. * If the traction belt is worn, loose, or broken, or if the traction belt is off the pulley, contact an Authorized Service Dealer.

Toro 72105 Wheel Horse 268HE Specifications

General

Engine	Briggs & Stratton 12.5 HP I/C
Cutting Width	38 in. (96.5 cm)
Transmission	Hydrostatic
Deck Material	Steel
Fuel Capacity	1.5 gallons
Fuel Tank Capacity	1.5 gallons

Summary

Safety Guidelines

General Safe Operating Practices

General safety guidelines for operating the machine, including personal protection and awareness.

Operation Safety and Slope Rules

Safe Machine Operation Procedures

Covers engine operation, load handling, traffic awareness, and stopping procedures.

Gasoline and Oil Handling Guidelines

Recommended Gasoline Specifications

Details the type of gasoline to use and important restrictions.

Gasoline Hazard and Safety Warnings

Explains the dangers of gasoline and how to avoid them.

Fueling and Additive Procedures

Safe Fuel Handling and Storage

Provides guidance on safe fueling procedures and container use.

Tractor Controls Overview

Engine Starting and Stopping

Engine Starting Procedure Steps

Step-by-step guide to starting the engine, including choke and PTO.

Power Take Off (PTO) Operation

Engaging and Disengaging PTO

Describes how to operate the Power Take Off (PTO) for attachments.

Safety Interlock System Explained

Understanding Safety Interlock Functions

Explains how the safety system prevents operation under certain conditions.

Operating in Reverse with Interlock Deactivated

Covers the interlock for reverse operation and its temporary deactivation.

Safety Interlock System Testing

Hazards of Reverse Operation

Highlights dangers associated with mowing in reverse and how to avoid them.

Performing Safety Interlock System Test

Detailed steps to verify the proper functioning of the safety interlock system.

Driving and Stopping the Tractor

Air Cleaner Maintenance Procedures

Air Cleaner Service Specifications

Removing and Cleaning Air Cleaner Assembly

Air Cleaner Installation Guide

Engine Oil Checks and Specifications

Engine Oil Service Specifications

Information on oil change intervals, type, capacity, and viscosity.

Checking Engine Oil Level Procedure

Step-by-step instructions for checking the engine oil level.

Oil and Filter Change Procedures

Changing and Draining Engine Oil

Detailed steps for draining old oil and refilling with new oil.

Oil Filter Replacement Guide

Guide for replacing the engine oil filter, including preparation.

Spark Plug Service and Checks

Spark Plug Service Specifications

Checking and Installing Spark Plugs

Greasing, Lubrication, and Tire Pressure

Brake System Checks and Adjustments

Checking and Adjusting the Brake

Fuel Tank Draining Procedure

Fuel Filter and Wheel Alignment Checks

Toe-In Adjustment and Transaxle Fluid

Battery Service and Removal

Battery Service Specifications

Removing the Battery from Chassis

Battery Installation and Electrolyte Checks

Installing the Battery Securely

Checking and Adding Battery Electrolyte

Battery Charging Guidelines

Safe Battery Charging Procedures

Machine Cleaning and Storage

Troubleshooting Engine Problems

Starter Not Cranking Diagnosis

Diagnoses and solutions for when the starter motor does not engage.

Engine Starting Difficulties Troubleshooting

Addresses issues with the engine not starting or running rough.

Engine Power Loss Troubleshooting

Solutions for problems causing the engine to lose power.

Troubleshooting Machine Operation Issues

Engine Overheating Solutions

Troubleshooting steps for an overheating engine.

Abnormal Vibration Diagnosis

Identifies causes and solutions for unusual machine vibrations.

Machine Driveability Issues Troubleshooting

Addresses problems related to the machine not moving or driving correctly.

Related product manuals

Toro 72050 Wheel Horse 265H

Toro 72085 Wheel Horse 267H

Toro 266H Wheel Horse 72052

Toro 72211 417XT Wheel Horse

Toro 73449 Wheel Horse 314-8

Toro 71428 Wheel Horse XL 380H

Toro Wheel Horse 78350

Toro Wheel Horse 71227

Toro Wheel Horse 78345

Preview: Toro Wheel Horse XL380H 71252

Toro Wheel Horse XL380H 71252

Toro wheel horse 8-25

Toro WHEEL HORSE Series