Toro XL Series - HXL Hydro Transaxle Removal - 2001 and Later

XL HYDROSTATIC TRANSAXLES
3 - 16 XL Lawn Tractor Service Manual
13. Before installing the mower deck on the tractor,
check the routing of the drive belt (Figure 119).
Figure 119
mvc-0047
14. Install mower deck, refer to the "Mower" section
on page 6 - 1.
15. Install battery and battery tray. Note: If the
battery uses a drain tube, make sure the tube
is reinstalled through the rear hole in the
frame. Reconnect the battery cables and test the
tractor, making sure all safety devices are
operating (Figure 120).
Figure 120
mvc-647
HXL Hydro Transaxle Removal -
2001 and Later
1. Disconnect the battery cables and remove the
battery and battery tray. Remove the mower deck
(refer to the "Mower" section on page 6 - 1).
2. Raise the rear of the tractor and remove the right
and left rear tires. Put jack stands under the
frame, just in front of the transaxle (Figure 121).
Figure 121
MVC-0014
3. Loosen the left transaxle belt guide (Figure 122).
Figure 122
MVC-0016