Toyota 2F - Page 9

2-4
Fig. 2-1
Fig. 2 -2
Fig. 2-3
N.S.W .
AJternal6f
I ~:~:
L '
Fig. 2-4
ENGI NE TUNE-U P - Dr iv e Belt
A
,.
&!
~I
I 11
I
... I
-··
Others
A
F•n 6:9.
Puuov
AJt•NIOf
Cr•nk
Pu lley
On\1 Bell
---
J
DRIVE BELT
VISUAL CHECK
Cheek for
1 Crack s. de1enora11on. s1ro1chtng or wear
2. Adherence of 0 11 or grease
Improper beh-10-puHov
contact.
CHECK & ADJUST BELT TENSION
General de s tlnotlons
Wnh 10 kg (22 lbl of force. press on the belts
01 the poonls ondocated tn the figure. Tile bells
should deflect 1he amount specof1 ed
Drive be ll delloc 1ion
""'
NSW &
-0 1tlCt
8'CCPI
VtetOllol
avsu1h1n
Al,lStraha
t11tes
/\
New
7 9
13- 16
7 - 10
1)28-0 ....
mm
(061-0ed» 1028-0300
9 - 17
( 1n > Usoo
l03S
04)1
B
7 - tO
mm
!028-0391
-- - -
bl\l
USA
Vs1ng a Borroughs belt 1ons1 on gauge BT-33·
73F. adjust as follows.
Dr i ve be lt tension:
Air co n.
Now belt
Used belt
Oth ers
100 - 150 lbs
60 - 80 lbs
New b el t 12 0 - 170 lb s
Us ed belt 80 - 1 20 lb s
Fig. 2 -6
ENGINE TUN E-UP Battery
BATTERY
VI SUAL CHECK
Cheek for
I
Rusted
bauery suppon
2.
3.
Looso 1ormina1 connoc11ons.
Rusted or deteriora1od ter minals .
4. Damaged or leakong bauery
2-5
r ··
MEASURE SPECIFIC GRAVITY
Fig. 2-7
I TRANSLUCENT ~RY
1 ~ 2
Upf)e• lovel I
lOw61' l.ovcJ
L
_J
Fig. 2-8
r
BlACK ~£RY (5 I
~ TopVotw ~
nu
low
Chock the spec1 f1c gravity of tho e1ec -
1ro l y1e w 11h a hydrometer .
Specific gravity (w h en fully
c harged at 2o •c ( 68 °F)J:
1.25 - 1.27
Check 1ho elec 1r o1v1e Quami 1y of each cell
11 insulfocient refoll w11h distilled water .