Tylo 1105-140 User Manual

4211-83-G 09-29-16 7014024 314 SKLE 70 H
INSTALLATION AND OPERATING INSTRUCTIONS
Page 1
WARNING
SECTION 1: GENERAL INFORMATION
These heaters are ETL approved by Intertek for permanent installations and
electrical connections. Built with splash proof construction, the conducting
parts are protected against water. All wiring must be performed in
accordance with local codes. See Table 1 for wire and room size
requirements.
These heaters are free standing, secured to the oor with separate controls.
Do not take a sauna if using
alcohol, drugs or medications.
Pregnant women or persons
with poor health should
consult their physician before
using any sauna.
Caution re hazard: Do not use
the sauna room for drying
clothes, bathing suits, etc. Do
not hang towels above heater
or place any object other than
the rocks supplied on the
heater. If any darkening of the
wall around the heater is
noticed discontinue sauna use
immediately.
Inspect sauna regularly for
required maintenance to
heater, control and benches.
Replace wood surfaces which
show any signs of
deterioration.
The heater gets extremely hot
during operation and should
not be touched or burns may
result.
Minors should be adequately
supervised whenever near a
hot or warming sauna.
Sauna Heaters
Pro 10.5, 12.0, & 14.4 (Model # 1105-105, 1105-120 & 1105-140) or
Laava 10.5, 12.0, & 14.4 (Model # 1105-1052, 1105-1202 & 1105-1402) or
Octa 10.5, 12.0, & 14.4 (Model #1106-105, 1106-120, & 1106-140)
(With separate SC Control panel & contactor box)
Read all instructions carefully before installation.
Please leave all instructions and warranty with the owner.
WARNING
Prolonged exposure to elevated temperatures is capable of inducing
hyperthermia. Hyperthermia occurs when the internal temperature of the
body reaches several degrees above the normal body temperature of
98.6°F. The symptoms of hyperthermia include an increase in the normal
temperature of the body, dizziness, lethargy, drowsiness, and fainting. The
effects of the hyperthermia include failure to perceive heat, failure to
recognize the need to exit the room, unawareness of impending hazard,
fetal damage in pregnant women, physical inability to exit the room and
unconsciousness.
WARNING
The use of alcohol, drugs, or medication is capable of greatly increasing
the risk of fatal hyperthermia.
0
10
20
30
40
50
1
7
6
5
4
3
2
10
9
8
0
SET TIMER
SET TEMPERATURE
Sauna Heating
Room Light
TEMPERATURE
CONTROL
MODEL 19-8
Listed
Sauna heater
No. 339 B
U
L
R
Contactor Box
CB 1201-7-1
or
CB 1201-7-3
SC Control
1106-XXX
Octa Heater
1105-XXX
Pro Heater /
1105-XXX2
Laava Heater

Tylo 1105-140 Specifications

General

Brand	Tylo
Model	1105-140
Category	Plumbing Product
Language	English

Summary

SECTION 1: GENERAL INFORMATION

Sauna Usage Health and Safety

Critical health risks and safety precautions for sauna users, including hyperthermia and substance use.

SECTION 4: ELECTRICAL HOOK-UP

Installation Safety and Electrical Hazards

Essential safety advice concerning electrical hazards, water, and installation practices.

SECTION 2: MOUNTING OF SAUNA HEATER

Instructions for securely installing the sauna heater unit.

SECTION 3: PLACING OF ROCKS

Guidance on arranging sauna rocks for optimal heater performance and avoiding issues.

SECTION 7: OPERATION

MODEL SC-9 CONTROL PANEL

Instructions for operating the SC-9 control panel, including timer and thermostat settings.

MODEL SC-60 CONTROL PANEL

Instructions for operating the SC-60 control panel, including timer and thermostat settings.

Operational and Installation Safety Notes

Important safety guidelines for operating the sauna and installing components correctly.

SECTION 7: OPERATION, Continued

MODEL SC-Club CONTROL PANEL

Instructions for operating the SC-Club control panel, focusing on manual operation and safety.

SECTION 8: LIMIT CONTROL (RESET BUTTON)

Procedure for resetting the heater's high limit control in case of overheating.

SECTION 9: HOW TO TAKE A SAUNA

Guidelines and recommended practices for enjoying a sauna session.

DIAGRAM 7

Room Construction Details

Diagram illustrating sauna room construction materials and layers.

DIAGRAM 8

Diagram showing air inlet and outlet vent placement for proper sauna ventilation.

SECTION 10: WARNING PLACARDS

SECTION 11: ROOM CONSTRUCTION

Rules and requirements for safe and reliable sauna room construction.

Sauna Room Safety and Construction Warnings

Crucial warnings regarding placards, overheating, fire risk, door operation, and interior finishes.

SECTION 12: VENTILATION

SECTION 13: MAINTENANCE

Guidelines for keeping the sauna clean, odor-free, and well-maintained.

SECTION 14: TROUBLESHOOTING

Guidance for diagnosing and resolving common issues with the sauna heater.