Rev AA Introduction 6-1
6
Maintenance
Introduction
The maintenance of the printer includes the procedures that an operator or
a service technician can perform. This chapter describes the maintenance
tasks that the operators of the printer are allowed to perform. The other
maintenance tasks that only the trained service technicians and personnel
must perform are described in the Service Manual.
PERSONAL INJURY. It is possible that in a fault condition, heater
can reach 70
° C. Do not touch the plate on which heater is installed.
The failure to follow this warning can cause the personal injury.
Maintenance Schedule
Table 6-1 shows the maintenance schedule.
Interval Task
When the printer is
commissioned or if
the make-up
cartridges are
empty
Replace the smart cartridge.
Refer “Replace Smart Cartridges” on page 6-3.
Note: Ink cartridge will only be replaced when prompted.
Empty cartridge will remain in place during normal
operation.
As Required Clean the following parts of the printhead:
• Deflector Plate
• Gutter
Note: Check the quality of the print before you do the
maintenance.
Refer “Inspect the Printhead” on page 6-5, and “Clean
the Printhead” on page 6-6.
Clean the printer cabinet.
Every 2000 Hours Replace the back filter.
Table 6-1: Maintenance Schedule
To Next Page
Loading...