2
1. INTRODUCTION
ZEKS Hydronix™ Heatless Desiccant Dryers are designed to adsorb moisture from
compressed air. The dryers are constructed with two towers, each containing desiccant
beads, that alternate between online (drying) and offline (regenerating) modes, yielding a
continuous stream of dry air at the dryer’s outlet.
During normal operation, wet compressed air passes through the online tower and water
vapor present in the air is adsorbed (collected) on the desiccant beads. While air is being
adsorbed in the online tower, the moisture accumulated on the desiccant in the offline
tower is removed by a process called desorption (regeneration). After an initial rapid
depressurization, a portion of dried air from the online tower passes through the desiccant
bed, carrying the moisture off the beads and out the dryer’s exhaust.
The continuous, alternating process of adsorption and desorption is controlled using a
timer that switches the towers in a specific timed sequence. Very dry compressed air dew
points are achieved through the continuous switching and operation of this dryer. ZEKS
offers dryers to provide outlet air with either -40°F, -80°F or -100°F pressure dew point.
2. ABBREVIATED WARRANTY
ZEKS Hydronix desiccant dryers are warranted to be free from defects in material and
workmanship for a period of 12 months from the original date of shipment from the factory.
To allow the warranty to be in effect for 12 months from the date of equipment start-up,
the Warranty Registration Card must be completed and returned to ZEKS. Alternately, the
Warranty Registration Card may be completed online at www.zeks.com. The total
warranty period cannot exceed 18 months from the original date of shipment from the
factory.
Equipment must be installed and operated in accordance with ZEKS’ recommendations.
ZEKS liability is limited to repair of, refund of purchase price paid for, or replacement in
kind at ZEKS’ sole option, during the warranty time period stated above.
IN NO EVENT SHALL ZEKS BE LIABLE OR RESPONSIBLE FOR INCIDENTAL OR
CONSEQUENTIAL DAMAGES, even if the possibility of such incidental or consequential
damages has been made known to ZEKS Compressed Air Solutions. In addition, the
usual maintenance and replacement type products are not covered by this warranty.
The warranties expressed above are in lieu of and exclusive of all other warranties.
There are no other warranties, expressed or implied, except as stated herein. There are
no implied warranties of merchantability of fitness for a particular purpose, which are
specifically disclaimed.
To Next Page
Loading...
