Zelmer ZWT6024AB - Operation; Maintenance

30 WT-001_v01
Features
ZELMER cooker hood is used to extract cooking fumes.
It requires installing a duct extracting air to the outside.
Thelengthoftheduct(mostcommonlyatube∅120mm)
shouldnotexceed405m.
Afterinstallingtheactive-coallterwhichisavailableinthe
salesnetwork,thecookermayoperateasanodorabsorber.
Insuchacasethereisnoneedtoinstallanair-outletduct.
ThecookerhoodisaclassIIelectricalappliance.
Itisequippedwithanindependentlightingandanextractfan
withthreespeedsettings.
Thecookerhoodisdesignedforapermanentinstallationon
averticalwallabovethegasorelectriccooker.
Parts Fig. A
Thecookerhoodiscomposedofthefollowingelements:
1
Thehoodbodyequippedwiththefanunit.
2
Aluminumlters.
3
Lighting.
4
Extractingopening.
5
Controlpanel.
6
Checkvalve(enablingtheconnectionofanairgrate).
Assembly Fig. B
Installing the cooker hood
1
Markaverticallineonthewallindicatingthecenterof
thekitchenplate.
2
Dismantlethealuminumgreaselter.
3
Put the housing of the hood against the wall with its
center marked on a central, vertical line with a minimum
650 mm distance from the lower area of the hood to the
surfaceholdingthedishesonthehotplate.
NOTE: Make sure the housing is leveled.
4
Markthepositionoftheassemblyholesonthewall.
5
Drilltheholesmarkedonthewallusingadrillwiththe
diametercorrespondingtotheenclosedrawlplugs,insertthe
rawlplugsintheholesandxthecookerhoodhousingtothe
wall(thehoodmayalsobeinstalledtotheunitbymeansof
fourscrews).
6
Installthealuminumanti-greaselter.
7
Plugintheappliance.
Plug in and operation control
Afterpluggingtheappliancein(accordingtothepreviously
describedrequirements),checkifthecooker hood lighting
worksandifitsmotoroperatescorrectly.
Afterinstallingthecookerhood,thesocketshouldbeeasily
accessibleinordertounplugtheappliance.
Setting the operation mode Fig. C
Settingtheextractionoperationmode
Whentheextractionoperationmodeison,theairiscarried
outinaspecialduct.Inthismode,acheckvalvewithtwo
small aps should be installed in order to prevent the air
fromreturningfromtheventilationduct.Itisalsoadvisableto
removethecarbonlter(ifthereisone).
Thehoodisconnectedtotheair-outletbymeansofaxed
orexibleduct,120mmindiameter(installedonthecheck
valve)andappropriateductclampswhichmaybeboughtin
specialsupplystores.Theconnectionshouldbeonlydone
byaqualiedinstaller.
Settingtheodorabsorberoperationmode
Inthismodethelteredairreturnstothecyclebytheinlet.
Thismoderequiresaninstalledcarbonlter,aswellasan
outletforthelteredairfromtheunit.
Operation Fig. D
Control panel
The cooker hood can be controlled using an integrated
switch.
0–motoroff,
1–rstoperationspeed,
2–secondoperationspeed,
3–thirdoperationspeed,
–lighton/off.
Thisadjustmentallowssettingtheoptimalfanspeedforthe
user’sneedswithaminimalnoiselevel.
The speed of the fan
In order to start or change the speed settings of the fan,
catchholdofaspecialcavityinthehousing,andthensetthe
appropriatespeedbymeansofswitches.
Thelowestandmediumspeedsettingsareusedinnormal
conditions and low cooking fume intensity. The highest
speedsettingshouldbeusedonlyincaseofanintenselevel
ofcookingfumese.g.duringfryingorgrilling.
Cleaning and maintenance Fig. E
Maintenance
Regular cleaning and maintenance will guarantee a good
andfailure-freeoperationofthecookerhoodandwillprolong
itsusefullife.Makesurethealuminumltersandtheactive-
coal lters are replaced according to the manufacturer’s
recommendations.
Anti-greasealuminumlters
1
Cleaning
In case of a normal operation of the cooker hood, the
aluminum anti-grease lters should be cleaned every two
monthsinadishwasherormanuallywiththeuseofamild
detergentorliquidsoap.