27
26
C=Check CA=Check Adjust R=Replace S =Service
CL=Clean and Lubricate
L=Lubricate
Remarks
Pre-
Operation
20 rounds
20 hours
20 hours
160kms(
Every
Month)
125
rounds
125 hours
600 miles
1000kms (
Every 6
250 rounds
250 hours
1200 miles
1000kms(
Every
Years)
500 rounds
500 hours
2500 miles
4000kms(
Every 2
Years)
1000
rounds
1000 hours
5000 miles
8000kms
(Every 4
Page
Charge
Cl ean Ba tter y top s ,for
tightness of hold-down screws
and terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure tread
depth tire surface for damage
Check bode and chassis,for damage
Check tightness of all bolts,nuts and
screw
Check reverse buzzer
Pre-Operation
Every month
Check electrolyte level
C h e c k f o r l o o s e o r b r o k e n
connectionsw
C l e a n L u b e P e d a l
control area
Check all wire insulation for crack
and/or worn spots
Check shock absorbers for oil
leaks and damaged springs
Perform a discharge test
protectant
Check shoe lining thickness
and rear axle beating play
C h e c k s t e er i n g k n u ck l e
bushing freeplay/Adjust wheel
alighment
Check wheel not tightness
front wheel bearing play
Check gear box oil level and
leakage
C h e c k f o r g r e a s e
leakage;adjust gear box if
Replace gear box oil
Check operation and adjust pedal
stop if necessary
Every 6 month
Every year
Every 4 month
Items without a page number referene should be serviced by approved
agent or qualified technician.
This manual doesn't contain these procedures.They are containerd in the
Service Manual
CHASSIS PREPARATION
1. Verify the air pressure of the tire is
25psi (4kgf/cm3);
2. Clean the outside of the car with
anti-rust oil;
3. Cover the car and store it in a dry and
well-ventilated place.
BATTERY PREPARATION
1. Recharge the batteries and check the
fluid levels at least once a month.
2. Disconnecting cables in case of long
storage.
3. Clean the top of the batteries with
baking soda and water so as to avoid
erosion.
Cleaning products are forbidden to
put into battery cells
CAUTION
Perform the following preparations when
leaving your golf car unused for a long
time:
NOTE:
Turn the main switch key to the "OFF"
position, remove the key, and put it in a
safe place.
Storage
Maintenance
To Next Page
Loading...