Aerco KC Series User Manual

APPENDIX G
G-1
CLOSURE SWITCH
PROOF OF
GRN
WHT
60 Hz
120 VAC IN
20 A
NEU GND HOT
NC
C
GNH
GND
H
G
N
123456123456789
123456789101112131415
123456789101112
CONTROL BOX CONNECTORS
LOW GAS PRESS. SW.
BLOWER PROOF SW.
SAFETY SHUTOFF VALVE
OVER TEMPERATURE SWITCHES
BLOWER
IGNITOR
TRANSFORMER
WATER LEVEL PROBE
FLAME ROD
AC WIRING BOX
SHELL
TEMP.
SENSOR
GAS FIRED
SYSTEM SCHEMATIC
161613
16-PIN CONNECTOR
19-PIN CONNECTOR
9-PIN CONNECTOR 7-PIN CONNECTOR
MANUAL RESET
HIGH GAS PRESS. SW.
BLK
STEPPING
MOTOR
PURGE
POSITION
IGNITION
POSITION
SWITCH
SWITCH
AIR/FUEL VALVE
BLK
YEL
WHT
53
5K
C
B
A 3
RED
GRN
BLU
2
10K
1
(KC 1000)
150 151153
152 153
152
151
150
7
133 134
1819 17 16
141516 13
154
AUTO RESET
IGNITION
265 200
BLOWER
XFORMER
RELAY
24 VAC
194 193 192 191 190 195
201 206 209 208 210 203 202 204
FUSE FUS E
203
206
207
265
205
210
204
202
207
209
200
201
SENSOR
* FFWD
TEMP.
180
* BTU PUMP
183
183
184
182
191
141
184
194
193
137
155
136
154
135
192
138 182
140
190
195
172
171
170
169
168
167
166
165
164
163
162
161
149
148
147
146
145
141
149
148
146145
147
181
136
137
209
208
* WATER HEATERS ONLY
6-PIN CONNECTOR
SHEET 1 OF 2
321
TO CONTROL BOX
320
321
322
TO BURNER
GND
AS FOLLOWS UNLESS OTHERWISE SPECIFIED
THIRD ANGLE PROJECTION
ALL DIMENSIONS ARE IN INCHES AND ALL TOLERANCES ARE
XX ±.015 XXX ± .005 FRACTIONS 1/32± ANGLES ±1°
PERPENDICULARITY/PARALLELISM/FLATNESS .003 TOTAL
DIAMETERS ON A COMMON AXIS
ALL DIMENSIONS ARE AFTER FINISH OR PLATING
RELEASED FOR PRODUCTION
THESE DRAWINGS AND/OR SPECIFICATIONS ARE THE PROPERTY OF AERCO INTERNATIONAL, INC. THEY ARE ISSUED IN STRICT CONFIDENCE AND
SHALL NOT BE REPRODUCED, COPIED, OR USED AS THE BASIS FOR MANUFACTURE OR SALE OF APPARATUS WITHOUT PERMISSION OF THE OWNER.
FIM
A
REVISIONS
REV ECO
061302 MD
CK'D
DATE BY
159 PARIS AVE, NORTHVALE, N.J.
061302MD
ORIGINAL
B
DRAWN BY:
DATE:
DATE:CHECKED BY:
DWG. SIZE
MAT'L SPEC.:
TITLE
.005 TOTAL
C
REVDWG. NO.:
B
FYP
ADDED GROUND WIRES 320, 321 & 322
100703 JM 031603
GENERAL CORRECTIONS TO SCHEMATIC
C
GKU
MC
173
1K
INTERNATIONAL INC.

Aerco KC Series Specifications

General

Brand	Aerco
Model	KC Series
Category	Water Heater
Language	English