Aircel VF-200 Installation And Operation Manual

52 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

Throughout this manual,

signal words are present to

advise of safety precautions

and/or standard practices.

Obey these signal words as defined

below:

DANGER! - indicates an

imminently hazardous situation

which, if not avoided, will result

in death or serious injury.

WARNING! - indicates a

potentially hazardous situation

which, if not avoided, could

result in death or serious injury.

CAUTION! - indicates a

potentially hazardous situation

which, if not avoided, may

result in minor or moderate

injury.

Notice: - used to address

practices not related to personal

injury.

This manual is property of the owner, and should be left with the unit when

start-up is complete. Aircel LLC. reserves the right to change design and

specifications without prior notice.

Installation,

Operation, and

Service Information

Aircel

VF Series Non-Cycling Refrigerated Air Dryer

Models VF-10, 15, 25, 40, 50, 60, 75, 100, 125, 150, 200, 250,

300, 400, 500 600, 800, 1000, and 1200

Installation

and Operation Manual

Table of Contents

Other manuals for Aircel VF-200

User Manual84 pages

Questions and Answers:

D
Daniel PowellAug 8, 2025
What to do if my Aircel Dryer system is not working properly and there is water downstream?
- A
  Amber ClineAug 8, 2025
  If your Aircel Dryer system isn't working correctly and there's water downstream, several factors could be at play. The refrigeration compressor might be stopping because of a dirty condenser coil, leading to high pressure, so you should clean the condensing coil and make sure the unit has enough ventilation. Another reason could be the refrigeration compressor cycles on and off and can't keep suction pressure, in that case, inspect the condensing coil for any obstructions. If clear, use refrigerant pressure gauges to see if the unit is low on refrigerant. Also consider the possibility of low refrigerant levels, possibly due to a leak in the air-to-refrigerant side of the heat exchanger, so you should repair or replace the heat exchanger and recharge the system according to specifications.
M
Matthew PriceAug 17, 2025
Why is there water downstream of my Aircel Dryer system or no discharge from the separator/filter?
- K
  Kylie MorganAug 17, 2025
  There are several reasons why you might find water downstream of your Aircel Dryer system or a lack of discharge from the separator/filter. It could be due to a failed or short-circuited timer on the drain or a failed drain solenoid, in which case you should replace the timer drain. Another cause may be bulk liquid entering the dryer from upstream, so check the drains on the aftercooler or air compressor. Also, verify that the inlet compressed air temperature and CFM flow rate to the dryer do not exceed the dryer's capacity; adjust as needed to meet specifications. A leak in the air-to-air heat exchanger can also cause this issue, requiring replacement of the heat exchanger.

Aircel VF-200 Specifications

General

Brand	Aircel
Model	VF-200
Category	Dryer
Language	English

Related product manuals