American Standard D80-512 - User Manual

150158 Rev. 03 January-2011
OPERATING, INSTALLATION AND SERVICE MANUAL
COMMERCIAL GAS WATER HEATER
WITH FLUE DAMPER AND ELECTRIC
IGNITION SYSTEM WITHOUT FAN MOTOR
REQUIRES 120V A.C. POWER SUPPLY
WARNING: If the information in these instructions is not followed exactly, a fire
or explosion may result causing property damage, personal injury or death.
THIS APPLIANCE SHALL NOT BE INSTALLED IN ANY LOCATION WHERE
FLAMMABLE LIQUIDS OR VAPORS ARE LIKELY TO BE PRESENT.
FLAMMABLE VAPORS MAY BE DRAWN TO THIS WATER HEATER FROM OTHER
AREAS OF THE STRUCTURE BY AIR CURRENTS.
CAUTION THIS WATER HEATER SHOULD NOT BE USED TO HEAT A SPA OR HOT TUB
THIS WATER HEATER SHALL NOT BE INSTALLED IN BATHROOMS, BEDROOMS,
OR ANY OCCUPIED ROOM NORMALLY KEPT CLOSED.
WARNING
This water heater is equipped for one type gas only. Check the data plate near the control access panel for the correct gas. DO NOT
USE THIS WATER HEATER WITH ANY GAS OTHER THAN THE ONE LISTED ON THE DATA PLATE. Failure to use the correct gas
can cause problems which can result in DEATH, SERIOUS BODILY INJURY OR PROPERTY DAMAGE. If you have any questions or
doubts consult your gas supplier or gas company. Water heaters for bottled, propane or liquefied petroleum gas (LPG) are different from
natural gas models. A natural gas heater will not function safely on bottled, propane or liquefied petroleum gas (LPG) and no attempt
should be made to convert a heater from natural gas to any other gas. An odorant is added to the gas used by this water heater.
IF YOU HAVE QUESTIONS THAT ARE NOT ANSWERED IN THE MANUAL YOU MAY CALL THE TOLL
FREE NUMBER 800 900-9063 OR CONTACT US BY EMAIL AT: engineering@waterheaters.com.
DO NOT CONTACT US BY TELEPHONE OR EMAIL FOR WARRANTY REGISTRATION. YOUR WATER
HEATER SERIAL NUMBER IS ALREADY ON FILE. THE WARRANTY IS ACTIVATED AT THE TIME OF
PURCHASE. KEEP YOUR RECEIPT TO SHOW TO SERVICE PERSON IF SERVICE IS REQUIRED.
Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
l
Do not try to light any appliance.
l
Do not touch any electrical switch; do not use any phone in your
building.
l
Immediately call your gas supplier from a neighbor’s phone. Follow the
gas supplier’s instructions.
l
If you cannot reach your gas supplier, call the fire department.
Installation and service must be performed by a qualified installer,
service agency or the gas supplier.

Summary

Critical Safety Information

What to Do If You Smell Gas

Steps to take if a gas leak is detected, including safety precautions.

General Danger Warnings

Critical safety warnings regarding fire, explosion, and scalding hazards.

Flammable Vapors Hazard

Hazards associated with flammable vapors and storage near the appliance.

For Your Safety

General safety guidelines and warnings for operation and installation.

Installation Procedures

Installation Location and Clearances

Guidance on proper placement, clearances, and venting for safe installation.

Water and Gas Connections

Proper procedures for connecting water supply, gas piping, and leak checks.

Electrical Connections

Electrical connection requirements and safety precautions.

Operation and Temperature Control

Condensation Explanation

Explanation of condensation formation and its normalcy during operation.

Operating Instructions

Step-by-step guide for safely lighting and operating the water heater.

Water Temperature Regulation

How to adjust and regulate the water temperature for desired output.

Maintenance, Troubleshooting, and Parts

Common Complaints and Remedies

Troubleshooting common issues with their causes and suggested remedies.

Replacement Parts List

List of available replacement parts with part numbers and descriptions.

Replacement Parts Illustration

Diagrams illustrating the location of various replacement parts.

American Standard D80-512 Specifications

General

Brand	American Standard
Model	D80-512
Capacity	80 Gallons
Energy Source	Electric
Voltage	240V
Wattage	5500W
Type	Electric