\\Serveurslce3\DAO\Etude-3d\Aquaset\0-DOSSIER TECHNIQUES\1-sw-plaisance\ESW\09- Manuels Utilisateur\DOC UTILISATEUR ESB FRUKES 2012-11-K.doc VERSION 2012-11-K FR/UK/ES Page 18/39
B – THE LP PUMP
1 – LP PUMP INSTALLATION
The booster pump must be installed 200mm below the water line, between the hull valve and the filter 5µ (as indicated in Fig. installation on
board in Appendix). There should be no air accumulation.
Essential to use the pipe provided by SLCE respecting the diameters and type of hose (see installation drawing board 110121-08).
If the pump is placed too far or too high compared to the hull fitting, cavitation is possible. Cavitation produces jangling that might completely
destroy the pump
.
This type of LP pump prohibits operation without water. It’s important that the pump must be installed below the water line,
between the hull valve (V0) and the filter 5µ (4).
Some examples of LP pump installation:
- The pump is imperatively at 200 mm below the water line,
- The hull valve (V0) should be placed below the LP pump,
- The rising line should be installed above the LP pump, so as to avoid air accumulation or trapped air.
GOOD INSTALLATION BAD INSTALLATION
2 – LP PUMP – TYPE
Exists differents pumps according to the unit :
Rep
Référence Désignation
3
605031
656200-90
656224-90
605032
605033
6-56.202-90
6-56.203-90
Booster pump 330L
Electric motor 12VCC-125W
Electric motor 12VCC-150W
Booster pump 660 L
Booster pump 1000 L
Electric motor 12VCC-460W
Electric motor 24VCC-550W
A1/A2/A3
717361
Flexible hose steel spirale
20x27
B1/B2
717303 Flexible 19x27
719234 Straight M 1/2” x 19 ribbed
719242 Splined elbow M 1/2” x 19
The feed-wire is connected conforming to the electric diagram page 16
2.1 – MAINTENANCE OF THE PUMP
The only required maintenance of the pump, is to flush it with fresh water during cleaning operation of the unit.
NB:
A rinsing of the LP pump-barrel with fresh water before an operating stop for more than 3 days increases considerably the life of the LP
pump.
WATER LINE
200 mm
mini
WATER LINE
200 mm
mini
WATER LINE
200 mm
mini
To Next Page
Loading...
