Installation, Start--up, Operating and
Ser vice and M a int e nanc e Instr uc t ions
Series 100/A
313AAV/JAV PLUS 80X
4--WAY MULTIPOISE
INDUCED--COMBUSTION GAS FURNACE
INPUT CAPACI TIES: 45,000 THRU 135,000 BTUH
SAFETY CONSIDERATIONS 2........................
INTRODUCTION 3..................................
CODES AND STANDARDS 4..........................
Safety 4........................................
General Installation 5...............................
Combustion and Ventilation Air 5.....................
Duct Systems 5...................................
Acoustical Lining and Fib rous Glass Duct 5.............
Gas Piping and Gas Pipe Pressure Testing 5.............
Electrical Connections 5............................
Venting 5........................................
ELECTROSTATIC DISCHARGE PRECAUTIONS
PROCEDURE 5.....................................
LOCATION 6.......................................
INSTALLATION 10..................................
Upflow Installation 10..............................
Downflow Installation 11...........................
Horizontal Installation 13...........................
Filter Arrangement 14..............................
Air Ducts 14.....................................
Gas Piping 17....................................
115--V Wiring 22..................................
START--UP, ADJUSTMENT, AND SAFETY CHECK 36.....
General 36.......................................
Start--up Procedures 36.............................
Adjustments 36...................................
Check Safety Controls 39...........................
Checklist 40......................................
SERVICE AND MAINTENANCE PROCEDURES 43.......
Introduction 43...................................
Care and Maintenance 46...........................
Sequence of Operation 49...........................
Wiring Diagrams 51...............................
Troubleshooting 51................................
ama
REGISTERED
ISO 9001:2000
CERTIFIED
NOTE: Read the entire instruction manual before starting the
installation.
Portions of the text and tables are reprinted from NFPA 54/ANSI
Z223.1-- 2006E , with permission of National Fire Protection
Association, Quincy, MA 02269 and American Gas Association,
Washington DC 20001. This reprinted material is not the
complete and official position of the NFPA or ANSI on the
referenced subject, which is represented only by the standard in
its entirety.
To Next Page
Need help?
General