Bryant 577E Series - User Manual

577E Ultra Low NOx: Owner’s Information Manual
Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.
1
c
Owner’s Information Manual
A09033
Fig. 1 – Unit 577E
Our products are designed, tested and built in accordance with DOE standardized procedures; however, actual operating results and efficiencies may
vary based on manufacturing and supplier tolerances, equipment configuration, operating conditions and installation practices.
577E Ultra Low NOx
Preferred™15 and 16 SEER
2-Stage Packaged Air Conditioner and Single Stage
Gas Furnace
System With Puron® (R-410A) Refrigerant
Single and Three Phase
2-5 Nominal Tons (Sizes 24-60)
Technician Name
Phone Number
Address
Company Name
Date Installed
NOTE TO EQUIPMENT OWNER:
For your convience, please record the model and serial numbers of your new equipment in the spaces
provided. This information, along with the installation data and dealer contact information, will be
helpful should your system require maintenance or service.
UNIT INFORMATION
ACCESSORIES (List type of model #)
INSTALLATION INFORMATION
DEALERSHIP CONTACT INFORMATION
This manual must be left with the eqipment owner.
NOTE TO INSTALLER:
Model #
Serial #

Bryant 577E Series Specifications

General

Brand	Bryant
Model	577E Series
Category	Air Conditioner
Language	English

Summary

Safety Considerations

General Safety Practices

Covers installation, adjustment, alteration, service, use, and general safety symbols.

Carbon Monoxide Poisoning Hazard

Information and warnings about the risks of carbon monoxide poisoning.

Fire, Explosion, and Electrical Shock Hazards

Warnings regarding installation, service, water submersion, and gas leaks.

Electrical Shock Hazard During Maintenance

Safety instructions for performing maintenance, including power disconnect.

Unit Introduction and Operation

Unit Introduction

Overview of the packaged gas heat/electric cooling system and its refrigerant.

Starting or Shutting Off Unit

Step-by-step guide for starting and shutting down the unit's gas heating section.

Operating Your Unit

Cooling Mode Operation

Explains how the unit operates in cooling mode based on thermostat settings.

Gas Heat Mode Operation

Explains how the unit operates in heating mode based on thermostat settings.

Maintenance and Service

Routine Maintenance

Guidelines for general routine maintenance tasks for the HVAC system.

Clearing Unit Area

Instructions on keeping the area around the unit clear for proper airflow.

Air Filters

Guidance on checking, cleaning, and replacing air filters for optimal performance.

Component Specific Maintenance

Fans and Fan Motors

Advice on checking fan wheels, housings, and motor shaft bearings.

Heat Exchanger

Recommendation for professional inspection and cleaning of the heat exchanger.

Indoor and Outdoor Coils

Guidance on professional cleaning of the unit's cooling coils.

Electrical Controls and Refrigerant Circuit

Notes on checking electrical controls and refrigerant circuit, recommending dealer service.

Troubleshooting and Warranty

Burn Hazard

Cautionary note about hot components in the heating section after startup.

Warranty Certificate

Information regarding the unit's limited warranty coverage.

Before You Call for Service

Checklist for easily-solved problems before contacting a service dealer.

In Case of Trouble

Procedure to follow if unit performance remains unsatisfactory after checks.