Camus Hydronics DFH/W1502 - User Manual

6226 Netherhart Road, Mississauga, Ontario, L5T 1B7
99-0050
Rev. 6.7
INSTALLATION OPERATION
AND SERVICE MANUAL
DYNAFLAME® SERIES
GAS FIRED COMMERCIAL COPPER TUBE AND STAINLESS
STEEL BOILERS
NON-CONDENSING
Models; DFH/W500, 750, 1100, 1200, 1500, 1750, 2000, 2500,
3000, 3500, 4000, 4500, 4504, 5000, 5004, 6004
NEAR-CONDENSING (DFX)
Models; DFH/W501, 751, 1101, 1201, 1501, 1751, 2001, 2501, 3001,
3501, 4001, 4501, 4514, 5001, 5014, 6014
CONDENSING
Models; DFH/W502, 752, 1102, 1202, 1502, 1752, 2002, 2502, 3002,
3502, 4002, 4502, 4524, 5002, 5024, 6024
H
HLW
W
W
A
A
R
R
N
N
I
I
N
N
G
G
:
:
If the information in these instructions is not followed
exactly, a fire or explosion may result causing property
damage, personal injury or death
Do not store or use gasoline or other flammable
vapours and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
o Do not try to light any appliance,
o Do not touch any electrical switch; do not
use any phone in your building,
o Immediately call your gas supplier from a
neighbour’s phone. Follow the gas
supplier’s instructions,
o If you cannot reach your gas supplier, call
the fire department.
Qualified installer, service agency or the
gas supplier must perform installation and
service.
To the
I
nstaller:
After installation, these instructions
must be given to the end user or left on or near the
appliance.
To the End User: This booklet contains important
information about this appliance. Retain for future
reference.
CAMUS® HYDRONICS LTD.

Summary

Installation Operation and Service Manual

Safety Warnings and Instructions

Critical safety information for installers and owners.

Part 1 General Information

Special Instructions to Owner

Guidance for owners regarding installation and safety compliance.

Ignition Process

Detailed steps of the burner ignition sequence.

Clearance from Combustible Material

Required clearances for safe installation around combustibles.

Installation Procedure and Location

Guidelines for selecting appropriate installation locations and procedures.

Part 2 Air Supply & Venting

General Venting Guide

Essential principles for air supply and venting systems.

Vent Termination Clearances

Required clearances for vent termination locations.

Part 3 Gas Connection

Gas Connection

General requirements for connecting the gas supply.

Air;Gas Ratio Valve

Function and adjustment of the air/gas ratio control valve.

Checking Gas Supply Pressure

Steps to verify gas supply pressure.

Part 4 Water Connection

Freeze Protection

Methods and considerations for protecting the appliance from freezing.

Part 5 Electrical & Controls

Electrical Connections

Requirements for electrical connections and voltage.

Part 6 SOLA Control Panel

Appliance Temperature Controller

Overview of the SOLA controller, its functions, and display.

Configure Menu

Navigation and access to boiler configuration settings.

Lead Lag Operation

Part 8 Field Startup Procedure

Checking the Installation

Inspection of water, gas, and electrical connections.

Checking the Construction

Fire Testing

Procedures for performing fire testing and adjusting combustion.

Part 9 Trouble Shooting

Flame Failure

Analysis and solutions for flame failure issues.

Flame Disappears During a Run Cycle

Troubleshooting steps when flame disappears during operation.

Noisy Operation

Auto Reset High Limit Trips

Troubleshooting auto reset high limit trips.

Delta-T Limit Tripped

Diagnosing and resolving Delta-T limit errors.

Sensor Not Connected

Flame Detection Issues

Addressing problems with flame detection.

Part 10 Maintenance

Examine the Venting System

Condensation Treatment

Burner Maintenance

Procedures for burner inspection, removal, and cleaning.

Changing the Hot Surface Igniter

Primary Heat Exchanger Inspection

Part 13 Electrical Diagrams

Electrical Diagrams

Schematics showing appliance electrical connections and wiring.

Honeywell SOLA Lead Lag Operation Up to 12 Boilers

Lead Lag Setup Overview

Configuration for lead lag operation of multiple boilers.

Sensor Wiring and Operation

Warranty

General Warranty Terms

Conditions and limitations of the appliance warranty.

Heat Exchanger Warranty

Camus Hydronics DFH/W1502 Specifications

General

Brand	Camus Hydronics
Model	DFH/W1502
Category	Boiler
Language	English