Carrier AquaEdge 19XR

To Next Page

To Previous Page

113

APPENDIX C — MAINTENANCE SUMMARY AND LOG SHEETS (cont)

19XR Monthly Maintenance Log

NOTE: Equipment failures caused by lack of adherence to the Maintenance Interval Requirements are not covered under warranty.

MONTH 1 2 3 4 5 6 7 8 9 10 11 12

DATE / / / / / / / / / / / / / / / / / / / / / / / /

OPERATOR

UNIT SECTION ACTION UNIT ENTRY

COM

PRESSOR

Change Oil Charge yes/no

Change Oil Filter yes/no

Send Oil Sample Out for Analysis yes/no

Leak Test ppm

Inspect Compressor Rotors yes/no

Bearing Inspection yes/no

COOLER

Inspect and Clean Cooler Tubes yes/no

Inspect Relief Valves yes/no

Leak Test ppm

Record Water Pressure Differential (PSI) PSI

Inspect Water Pumps yes/no

Eddy Current Test yes/no

CONDENSER

Leak Test ppm

Inspect and Clean Condenser Tubes yes/no

Record Water Pressure Differential (PSI) PSI

Inspect Water Pumps and Cooling Tower yes/no

Inspect Relief Valves yes/no

Replace Refrigerant Filter Drier yes/no

Inspect Float Valve and Strainer yes/no

Eddy Current Test yes/no

CONTROLS

eneral Cleaning and Tightening Connections yes/no

Check Pressure Transducers yes/no

Confirm Accuracy of Thermistors yes/no

Perform Automated Controls Test yes/no

STARTER General Tightening and Cleaning Connections yes/no

OIL RECLAIM

nspect Oil Sump Strainer yes/no

Inspect Oil Sump Heater yes/no

Carrier AquaEdge 19XR - Page 113