Carrier TRANSICOLD 69UG15 Series - Table of Contents

ii
T−343
TABLE OF CONTENTS − Continued
PARAGRAPH NUMBER Page
TROUBLESHOOTING 3−1.........................................................................
3.1 DIESEL ENGINE 3−1.....................................................................
3.1.1 Engine Will Not Start 3−1..............................................................
3.1.2 Engine Starts Then Stops 3−1..........................................................
3.1.3 Engine Will Not Shut Off 3−2...........................................................
3.1.4 Starter Motor Malfunction 3−2..........................................................
3.1.5 Malfunction In The Engine Starting Circuit 3−2............................................
3.1.6 Miscellaneous Engine Troubleshooting 3−3...............................................
3.2 BATTERY CHARGER (SOLID STATE) 3−3..................................................
3.3 ALTERNATING CURRENT GENERATOR 3−4...............................................
3.4 AUTO RE-START OPTION 3−5............................................................
3.5 DUAL SPEED OPTION 3−6................................................................
3.6 ELECTRONIC GOVERNOR MODULE 3−6..................................................
SERVICE AND PREVENTATIVE MAINTENANCE 4−1.................................................
4.1 INTRODUCTION 4−1.....................................................................
4.2 PREVENTATIVE MAINTENANCE SCHEDULE 4−1...........................................
4.3 BATTERY SERVICE 4−1..................................................................
4.4 ENGINE SERVICE AND COMPONENTS 4−1................................................
4.4.1 Bleeding the Fuel System 4−1..........................................................
4.4.2 Servicing Fuel Pump Internal Filter 4−1..................................................
4.4.3 Fuel Filter 4−1........................................................................
4.4.4 In−Line Fuel Strainer (Option) 4−1.......................................................
4.4.5 Cooling System 4−1...................................................................
4.4.6 Lube Oil Filter 4−2....................................................................
4.4.7 Servicing the Low Coolant Sensor (Option) 4−2...........................................
4.4.8 Servicing Low Oil Pressure Switch 4−2...................................................
4.4.9 Engine Speed 4−2....................................................................
4.4.10 Replacing the Engine Speed Sensor 4−2.................................................
4.4.11 Servicing Poly V-belt 4−3..............................................................
4.4.12 Engine Air Cleaner 4−3................................................................
4.4.13 Engine Crankcase Breather 4−4........................................................
4.4.14 Intake Heater Test 4−4.................................................................
4.4.15 Intake Heater Service 4−4..............................................................
4.4.16 Intake Heater Switch 4−5..............................................................
4.5 SERVICING THE ALTERNATING CURRENT GENERATOR 4−5...............................
4.5.1 Preventative Maintenance and Operating Precautions 4−5..................................
4.5.2 Generator Repair/Test Procedures 4−5...................................................
4.5.3 Bearing Replacement 4−6..............................................................
4.5.4 Generator Removal and Installation 4−7..................................................
4.6 GENERAL GENERATOR SET MAINTENANCE 4−7..........................................
4.6.1 Maintenance Of Painted Surfaces 4−7...................................................
4.6.2 Check and Replace Isolators/Shockmounts 4−8...........................................
4.7 UNIDRIVE TORQUE REQUIREMENTS 4−9.................................................
SCHEMATICS 5−1................................................................................
5.1 INTRODUCTION 5−1.....................................................................