CAT MATE 210 - Fitting Instructions; Important Safety Instructions

FITTING INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
• Readallinstructionsbeforeinstallingorusingthisproduct.
• Registeryourpurchaseon-lineatwww.pet-mate.com(seeguarantee).
• Donotallowchildrentoplaywiththisproduct.
• Inspectproductregularlyforcorrectoperationanddamage.Donotuseif
indoubt.
• Thisproductisdesignedforusewithpetsonly,asdescribedinthese
instructions.
• Thelockingsystemofthispetdoorisnotintendedasasecuritydevice.
• Thispetdoorisnotareresistantdoorandmustnotbeusedwherethere
isariskfromrespread.
• Theinstallerofthispetdoorisresponsibleforcomplyingwithallrelevant
buildingregulations.
• Duringinstallationofthispetdoortakeappropriatecare.Followsafety
instructionsforalltoolsandwearappropriatepersonalprotective
equipment.
• Disposeofallpackagingmaterialproperly.
NOTE: Plastic bags could cause suocation – keep away from children
and animals.
SAVE THESE INSTRUCTIONS
Fig. 1. Werecommendthatyouaskaglaziertocutaholeof223mm(8
3
/4”)
diameterinthepositionrequired.Werecommendthebottomoftheholeis
approximatelylevelwithyourpet’sstomach.NOTE: For existing toughened/
double / triple glazing, a new glass panel will be required.
Fig. 2. For glass panels 2 - 5mm (
1
/16” -
3
/16”): Carefullycutinteriorframe
(framewithoutswingingap)tomouldedstepwithahacksaworplastic
cuttingdisc.
Fig. 3.Positioncatapframeonoutsideofpanelandscrewinteriorframeto
itusingtheappropriatescrew/spacercombinationforyourthicknessofpanel,
(seetablebelow).Donotovertightenscrews.Coverscrewheadswiththe
capssupplied.
Door thickness Short screw Long screw
Spacer under
screwhead
2-10mm
(
1
/16”-
3
/8”)
✓ ✓
10-17mm
(
3
/8”-
11
/16”)
✓
17-23mm
(
11
/16”-
7
/8”)
✓ ✓
23-30mm
(
7
/8”-1
1
/4”)
✓
30mm +
(1
1
/4” +)
Use2o8g(Ø4.2)selftappingscrewscuttolength=
doorthickness+12mm(
1
/2”)
A helpful tip... Totrainyourcattousethecatap,propitopen,(e.g.witha
clothespeg),atrstandusefoodasanencouragement.
Hereby,PetMateLtd.,declaresthatthisproductisincompliancewiththe
essentialrequirementsandotherrelevantprovisionsofEUDirectives.All
DeclarationsofConformity(DoC)maybeviewedatwww.pet-mate.com/eudoc
approx.
125mm (5”)
Ø
223mm
(8
3
/ 4 ”)
1
2
3
approx.
125mm (5”)
Ø
223mm
(8
3
/ 4 ”)
1
2
3
approx.
125mm (5”)
Ø
223mm
(8
3
/ 4 ”)
1
2
3