Centurion RDO-10A - Door Height Adjustment; Door Travel Adjustment; Safety Reverse and Stop Configuration

6






Function
Adjuststheopendirectionslowstoppingpointtocaterfor
highdoors





Enabling
 Dip7“OFF”–doorsupto2.5metershigh
 Dip7“ON”–doorsover2.5metershigh


ImportantNote‐Whenadjustinglimitsalwaysensurethatthe Opener is disengagedfromthedoor and notconnectedto
thepowersupply
OpenDirection
 Movethedoorbyhandtothefullyopenposition
 RemovelightcovertoexposeLimitCams(Fig.7‐E&F)
 Loosenthe
3lockscrewssothattheCamsturnfreely.
 Rotatethe“Open”Cam(Fig.7‐E)inthedirectionofthe
limitswitchuntiltheswitchisheardto“click”
 Oncetheswitch“clicks”continuetorotatethecama
further5degreestowardstheswitch
 Checkadjustment
bypartiallyraisingandloweringthe
doorbyhand.Theswitchshould“click”approx50mm
beforethedoorstoppersreachthetrackstoppers
 IfnecessaryadjusttheOpenLimitCamaccordingly‐
turnthecamtowardsswitchtodecreasedoortravel
andawayfromtheswitchtoincreasedoortra vel.
Close
Direction
 Movethedoorbyhandtothefullyclosedposition
 Rotatethe“Close”Cam(Fig.7‐F)inthedirectionofthe
limitswitchuntiltheswitchisheardto“click”
 Oncetheswitch“clicks”rotatethecamby5degrees
backawayfromtheswitch

Checkadjustmentbypartiallyraisingandloweringthe
doorbyhand.Theswitchshould“click”approx20mm
beforethedoorreachestheground
 IfnecessaryadjusttheCloseLimitCamaccordingly‐
turnthecamtowardsswitchtodecreasedoortravel
andawayfromtheswitchtoincreasedoortra vel.

Retightenthe3lockscrewssothatthecamsare
securedfirmlyinplace


DuringaclosingmovementAutoReverseensuresthatthegaragedoorwillstopandreverse(SafetyReverse)whenit
encountersanobstructionthusensuringthesafetyofpeopleandproperty.Duringanopeningmovementthegaragedoor
willstop(SafetyStop)whenitencountersanobstruction.Theamountofforcerequired
tomakethegaragedoorSafety
Reverse/Stopcanbeadjusted.Alowforcevalueensuresmaximumsafety,butrequiresaverywellsprungandinstalled
doorinordertoavoidghosting(falsesafetyreversing/stopping).Ahighforcevalueensuresthatevenabadlysprungor
worndoorwillworkwithout
ghosting.Thefollowingdetailsthecorrectforcevaluesetupandadjustmentprocedure.

AMODE

Description
Themostsensitivesystembestsuitedforuseonnewwell
sprungdoors‐automaticallycompensatesoneachandevery
cyclefordoorwearageingandseasonaltemperaturechange
forthelifetimeofthedoor
Function
DuringaclosingmovementtheOpenerwillSafetyReverse
uponencounteringanobstruction
Duringan
openingmovementtheOpenerwillSafetyStop
uponencounteringandobstruction
Enabling
 Switchpoweroffatpoweroutlet
 RemovetheLightCover
 SelectDip1(Fig.7‐G)to“ON”position
Learning
InordertoLearnSafetyReverseandSafetyStopvaluesthe
Openerwillberequiredto
complete6uninterruptedopen
andclosecycles.DuringthelearningprocesstheLED(Fig.7‐I)
willrapidblink.TheLEDwillextinguishoncelearningis
complete


Adjustment
RotatetheGreen“O ffset”AdjustPin(Diag.7‐C)inaclockwise
direction(towardsMax)toincreasetheforcerequiredto
makethegarage
doorSafetyReverseorStopandinananti
clockwisedirection(towardsMin)todecreasetheforce
requiredtomakethegaragedoorSafetyReverseorStop.
TestingCloseDirectionForce
Ensurethatthegaragedoorisrestingfirmlyagainstthe
ground.Openthedoorandplacea40mmthickblock
of
woodonthegroundunderthepathofthedoor.Nowclose
thedoor–ifthedriveforcevalueiscorrecttheopenerwill
stopandreversedirectionuponencounteringtheblockof
wood.Iftoolittleortoomuchforceisrequiredtomakethe
openerreverse
direction–turntheGreen“Offset”AdjustPin
(7‐C)5degreesintheappropriatedirection–clockwise
(towards“MAX”)toincreasetheamountofforceandanti
clockwise(towards“MIN”)todecreasetheamountofforce
andthenrepeatthetest.
ImportantNote:DuringLearning‐ifthedoorload
isexcessive
OpenerwillstopandCourtesyLightwilldoubleblink

12.DoorTravelAdjustmen
t

SETTINGSANDADJUSTMENTS
13.
S
afetyReverse
11.DoorHeigh
t
