Chef 540MM - Cleaning Procedures; Oven Interior, Shelves, and Grill Cleaning; Hotplates, Burners, and Airwash Door Cleaning

Oven
• Makesureovenknobsareintheoffposition.
• Cleanimmediatelyafteruse,awarmoveniseasiertoclean.
• Usedetergentandhotwater(andhouseholdammonia/
cloudy ammonia if necessary) and a soft cloth. Dry thoroughly.
• Removeshelveswhencleaningoven.
• Ifthereisabuild-upofgrease,placeasmallovenproof
dish containing ¼ cup (62mL) household ammonia/cloudy
ammonia and ¾ cup (187mL) water in the oven. Heat
ovento110°C,turnovenoffwhen110°Cisreached
and leave over-night. The fumes will loosen stubborn
grease and stains. Remove bowl, wash with hot, soapy
water and dry well before closing oven door again.
Oven Shelves
• Chromeshelves:usedetergentandhotwater.Ifverydirty
use a non-abrasive nylon scourer.
• Enamelshelving:usedetergentandhotwater.Ifverydirty
a non-abrasive nylon scourer.
• Donotcleanovenpartswithabrasiveorcaustic-typecleaners.
Oven – Grill Dish and Insert
• Aftereveryuse,andwhilestillwarm,sprinklegrillinsert
with detergent and cover with wet paper towel this will
loosen food particles and grease.
• Washpanandgridwithhot,soapywaterwithalittle
household ammonia/cloudy ammonia added. Rinse and
dry before replacing in position.
Ceramic Hotplates
• Cleanwithdetergentandhotwaterandpolishwith
a soft cloth.
• Forhardertocleanspillsabladescraperissupplied.
• Aluminiumfoil,plasticandhighsugarcontentfoodcan
cause pitting if not removed before the hotplate has cooled.
Radiant Hotplates
• Canbeliftedupwardstocleananyspillageunderneath
the trim rings.
Solid Hotplates
• Solidhotplatesarettedwithstainlesssteeltrimrings,
which after initial use change colour to light brown. This is
a normal characteristic of stainless steel and will not affect
the operation or performance of your hotplates.
• Cleanoffanyspillageafterhotplatehascooleddown
• Atweeklyintervals,cleanhotplatewithanylonscouring
pad and soapy water. Wipe clean then warm hotplate
for 30 seconds to dry surface.
• Apply‘ShineOn’.Tohardenallowcoatingtosethotplate
on high for 3 minutes
Gas Burners
• Flameportblockagesshouldberemovedbythemeans
of a small metal cake skewer or nylon brush.
• Cleandirtysparkplugsverygentlywithanylonscourer.
Do not use steel wool. Do not bend spark plug as it
may break
Cleaning the airwash door
Cool air circulates through the door to lower the surface
temperature on the outside of the oven door.
To remove the inner glass for cleaning
• Carefullyremovethescrews,retainingplatesandrubber
pads as depicted in the diagram below.
• Removeglassgently–remembertousebothhands.
• Wipeinnerandouterglassgentlywithdetergentand
hot water.
• Wipecleananddrythoroughly.Donotovertightenthe
screws when reassembling door.
Glass retaining plates
and rubber pads
Airwash
inlet vent
Airwash outlet vent
C
O
OL
A
IR
WARNING
warning
DO NOT use the oven with out the inner door glass fitted.
cleaning
the oven
Chef540UprightCookerCLEANINGTHEOVEN11