Continental Fireplaces CDV36PTR - Table of Contents

2
W415-0802 / C / 12.15.10
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 CDV36 DIMENSIONS 5
2.2 BCDV36 DIMENSIONS 5
2.3 GENERAL INSTRUCTIONS 6
2.4 GENERAL INFORMATION 7
2.5 RATING PLATE INFORMATION 8
3.0 VENTING 9
3.1 VENTING LENGTHS AND COMPONENTS 10
3.2 TYPICAL VENT INSTALLATION 11
3.3 SPECIAL VENT INSTALLATIONS 13
3.3.1 PERISCOPE TERMINATION (CDV36 AND BCDV36) 13
3.3.2 CORNER TERMINATION 13
3.4 MINIMUM AIR TERMINAL LOCATION CLEARANCES 14
3.5 VENTING APPLICATION FLOW CHART 15
3.6 DEFINITIONS 16
3.7 ELBOW VENT LENGTH VALUES 16
3.8 TOP EXIT HORIZONTAL TERMINATION 17
3.9 REAR EXIT HORIZONTAL TERMINATION 19
3.10 TOP OR REAR EXIT VERTICAL TERMINATION 21
4.0 PRE-INSTALLATION PREPARATION 23
4.1 CDV36 REAR EXIT 23
4.2 CDV36 TOP EXIT 23
4.3 BCDV36 REAR EXIT 24
4.4 BCDV36 TOP VENT 24
5.0 INSTALLATION 24
5.1 WALL AND CEILING PROTECTION 24
5.1.1 CDV36 HORIZONTAL INSTALLATION 25
5.1.2 BCDV36 HORIZONTAL INSTALLATION 26
5.1.3 VERTICAL INSTALLATION 26
5.2 USING FLEXIBLE VENT COMPONENTS 27
5.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 27
5.2.2 VERTICAL AIR TERMINAL INSTALLATION 28
5.2.3 APPLIANCE VENT CONNECTION 28
5.3 USING RIGID VENT COMPONENTS 29
5.3.1 HORIZONTAL AIR TERMINAL INSTALLATION 29
5.3.2 EXTENDED HORIZONTAL AND CORNER TERMINAL INSTALLATION 29
5.3.3 VERTICAL AIR TERMINAL INSTALLATION 30
5.3.4 CDV36 RESTRICTING VERTICAL VENTS 30
5.4 MOBILE HOME INSTALLATION 31
5.5 GAS INSTALLATION 32
5.6 OPTIONAL WALL SWITCH 33
6.0 FRAMING 33
6.1 CDV36 FRAMING 33
6.1.1 MINIMUM FRAMING DIMENSIONS 34
6.2 BCDV36 FRAMING 36
6.2.1 MINIMUM FRAMING DIMENSIONS 37
6.3 MINIMUM ENCLOSURE CLEARANCES 38
6.3.1 CDV36 38
6.3.2 BCDV36 39
6.4 MINIMUM MANTEL CLEARANCES 39
6.5 BCDV36 NAILING TAB INSTALLATION 40
7.0 FINISHING 41
7.1 DOOR REMOVAL AND INSTALLATION 41
7.2 LOUVRE INSTALLATION 42
7.3 LOG PLACEMENT 43
7.4 CHARCOAL EMBERS 44
7.5 VERMICULITE (MODEL CDV36 ONLY) 44
7.6 GLOWING EMBERS 44
7.7 LOGO PLACEMENT 44
7.8 OPTIONAL ROCK KIT 45
8.0 OPTIONAL BLOWER INSTALLATION 46
9.0 OPERATION 48
10.0 ADJUSTMENT 49
10.1 PILOT BURNER ADJUSTMENT 49
10.2 VENTURI ADJUSTMENT 49
10.3 FLAME CHARACTERISTICS 50
11.0 MAINTENANCE 50
11.1 DOOR GLASS REPLACEMENT 51
11.2 CARE OF GLASS 51
12.0 REPLACEMENTS 52
13.0 TROUBLE SHOOTING 56
14.0 WARRANTY 58
15.0 SERVICE HISTORY 59