Continental Girbau CG50-60 User Manual

For replacement parts, contact the distributor from which the dryer
was purchased or
Continental Girbau, Inc.
®
2500 State Road 44
Oshkosh WI 54904
Telephone: (920) 231-8222 / Fax: (920) 231-4666
www.cont-girbau.com
010201JEV/calbert CGI Part No. A113301
CG50-60
(Gas DSI/Electric/Steam)
Installation Manual
WARNING: For your safety the information in
this manual must be followed to minimize the
risk of fire or explosion or to prevent property
damage, personal injury or death.
— Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Clear the room, building or area of all
occupants.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call
the fire department.
— Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
AVERTISSEMENT: Assurez-vous de bien
suivre les instructions données dans cette notice
pour réduire au minimum le risque d’incendie
ou d’explosion ou pour éviter tout dommage
matériel, toute blessure ou la mort.
— Ne pas entreposer ni utiliser d’essence ni
d’autres vapeurs ou liquides inflammables à
proximité de cet appareil ou de tout autre
appareil.
— QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
• Ne pas tenter d’allumer d’appareils.
• Ne touchez à aucun interrupteur. Ne pas
vous servir des téléphones se trouvant dans
le bâtiment.
• Évacuez la pièce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur
de gaz depuis un voisin. Suivez les
instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur
de gaz, appelez le service des incendies.
— L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualifié
ou par le fournisseur de gaz.

Continental Girbau CG50-60 Specifications

General

Brand	Continental Girbau
Model	CG50-60
Category	Dryer
Language	English

Summary

Important Information and Safety Precautions

Receiving and Handling

Safety Precautions

Essential safety guidelines for dryer operation, installation, and maintenance.

Specifications and Component Identification

Specifications

Technical details including dimensions, electrical, gas, and steam requirements for the dryer.

Installation Procedures

Location Requirements

Criteria for selecting an appropriate and safe installation location for the dryer.

Unpacking and Setting Up

Dryer Enclosure Requirements

Fresh Air Supply Requirements

Exhaust Requirements

Guidelines for designing and installing the dryer's exhaust ductwork for safety and efficiency.

Electrical Information

Electrical Requirements

Mandatory electrical connection standards and safety compliance for dryer installation.

Electrical Service Specifications

Details on voltage, phase, and amperage requirements for electric dryer models.

Grounding

Gas Information

Gas Supply

Technical Gas Data

Piping and Connections

Preoperational Tests and Instructions

Gas Models Only Preoperational Tests

Safety Related Circuits Check

Starting the Dryer

Service and Parts Information

Service

Parts

Troubleshooting

Display and Power Issues

Troubleshooting for no LED display, power, or start issues.

Motor Operation Issues

Diagnosing issues with drive and blower motors not starting, stopping, or operating incorrectly.

Microprocessor Controller Issues

Troubleshooting error messages, keyboard input, and control board lock-ups.

Heating System Malfunctions

Diagnosing no heat, burner cycling, or indicator lights for heating components.

Operational and Performance Issues

Addressing problems like long drying times, noise, vibration, and incorrect flame.

Procedure for Functional Check of Replacement Components

Microprocessor Controller (Computer) Board Check

Direct Spark Ignition (DSI) Module Operation

Manual Reset Hi-Limit Instructions

Manual Reset Hi-Limit Instructions (Gas Models)

Instructions for resetting manual hi-limit thermostats on gas models.

Manual Reset Hi-Limit Instructions (Electric/Steam Models)

Instructions for resetting manual hi-limit thermostats on electric or steam models.