TROUBLESHOOTING CHART
PROBLEM
Will not start
Hard to start
Engine willnot tum
over
Engine clicks but will
not start ,
CAUSE CORRECTION
• Out of fuel.
• Engine not =CHOKED" prop-
erly. ,
• Engine flooded.
I
• Bad spark plug.
• Dirtyak filter.
• Dirtyfuel filter.
• Water in fuel.
• Loose or damaged widng. •
• Carburetor out of adjustment. , •
• Enginevalves out of adjust-
ment.
• Dirtyair titter.
• Bad spark plug.
• Weak or dead battery.
• Dirtyfuel tilter.
• Stale or dirtyfuel.
• Loose or damaged widng.
• Carburetor out of adjustment.
• Engine valves out of adjust-
ment.
• Clutch/brake pedal not
depressed.
• Attachment dutch is engaged.
• Weak or dead battery.
• Blownfuse.
• Corroded battery terminals.
• Looseor damaged widng.
• Faulty ignitionswitch.
• Faultysolenoid or starter.
• Faulty operator presence
switch(es).
• Weak or dead battery.
• Corroded battery terminals.
• Loose or damaged widng.
• Faulty solenoid or starter.
• Fill fuel tank.
• See "TO START ENGINE" in
Operation section.
• Walt several minutes before
attempting to start.
• Replace spark plug.
• Clean/replace air filter.
• Replace fuel filter.
• Drain fuel tank and carburetor,
refill tank with fresh
gasoline and replace fuel filter.
Check all widng.
See "To Adjust Carbureto¢' in
Service and Adjustments
section.
• Contact an authorized service
center.
• Clean/replace air filter.
• Replace spark plug.
• Recharge or replace battery.
• Replace fuel fitter.
• Drain fuel tank and refillwith
fresh gasoline.
• Check all widng.
• See -To Adjust Carburetor"in
Service and Adjustments
section.
• Contact an authorized service
center.
• Depress clutch/brake pedal.
• Disengage attad_ment clutch.
• Recharge or replace battery.
• Replace fuse.
• Clean battery terminals.
• Check all wiring.
• Check/replace ignitionswitch.
• Check/replace solenoid or
starter.
• Contact an authorized service
center.
• Recharge or replace battery.
• Clean battery terminals.
• Check all widng.
• CheckJreplacesolenoid or
starter.
32
To Next Page
Loading...
